2021 Hyundai Santa Fe power train problems

“On September 20, 2026, my 2021 Hyundai Santa Fe Calligraphy suffered sluggish acceleration while operating on a public roadway due to an internal dual-clutch transmission (DCT) failure. The Malfunction indicator light illuminated, and a diagnostic scan revealed stored history code P1C2D03, indicating a total breakdown of the high-pressure electric pump assembly. As of September 21, 2026 the vehicle is currently grounded at an authorized Hyundai dealership under an approved factory warranty repair Prior Authorization (PA) request. However the dealership has issued a written admission of "NO ETA" because the replacement transmission components are on an indefinite national backordered and are no longer being manufactured . Because the vehicle cannot be repaired in a reasonable timeframe due to a severe factory design defect , it remains unresolved.”

“The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving approximately 5-30 MPH, the transmission failed to shift properly, and the vehicle lost motive power. The engine warning light was illuminated. The contact stated that the failure was a recurring failure. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 22V746000 (Power Train); however, the failure persisted. The dealer was contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 78,000.”

“My check engine light came on, and my car was also feeling "sluggish" and slow to accelerate. I scheduled a service appointment at my local dealer 4 days later. At the appointment, the technician stated everything checked out okay and the check engine light was likely an "anomaly" or "outlier" but otherwise nothing to be concerned about since everything checked out "okay" and no problems were identified during their test drive. However, that very afternoon, I was driving down the interstate, where the posted speed limit is 70mph, when my check engine light came on again and suddenly lost power, drastically reducing my speed and could not accelerate faster than 39mph. Luckily, the interstate was not busy at the time (about 10:30-11:00 a.m. Saturday morning) and there were only less than 4 cars behind me that were able to easily switch lanes and pass me. I moved over to the shoulder to a complete stop and restarted my car. My check engine light remained illuminated and was still slow to accelerate and "sluggish" but was able to (slowly) reach interstate speed (60-70mph) until I reached an acceptable exit and safely made it to my destination. I have since used…”

“First instance at 50-55 mph the transmission violently shook the car when downshifting to accelerate on multiple occasions. Dealership diagnosed the problem as a faulty transmission and replaced it at 44064 miles on March 18, 2025. Second time the car failed to accelerate when merging into traffic while the engine revved very high. Again it was taken to the dealership and the diagnosis was faulty transmission. A second transmission was in stalled at 51331 miles. Second transmission began downshifting hard upon accelerating at highway speeds. Retuned to dealership and diagnoses was faulty fuel injectors and all four were replaced on April 7 at 52960 miles. On April 10, 2026 the car displayed a check engine light after the car began shuttering at highway speeds and was immediately returned to dealership where it’s pending a diagnoses. Failure to safely accelerate when merging make this vehicle a safety risk.”

“-shift lever in transmutation stopped working so car would go into auto shut off and then would not drive once I took my foot off the break. Would not switch gears or drive. Had to shut car off then turn back on to get it to switch gears. -safety was put at risk majorly. Car did that in 5 lanes of traffic with me and kids in car and couldn’t drive. We almost got hit. -dealership said no issues found until I took it in a second time for the same issue then they said it was the translation shift leaver. -Briggs Kia inspected it -no warnings at all -This happened MULTIPLE times. Put the most current date”

“I was about to turn into a 2 lane road and a warning came on my dash, "shifter system malfunction service immediately " my vehicle was in Drive I was unable to move my vehicle, unable to shift into any other gear. It was sudden with no warning or loss of power prior to the warning and loss of movement.”