2006 Hyundai Sonata suspension problems

“There is a recall for the rear lower control arms for the 2006 Hyundai sonata getting rusty and not performing. My car was taken in for an alignment and the mechanic said he isn’t able to make the toe match up to be in good driving standards. I tried reaching out to a Hyundai dealership and they checked the VIN and said they couldn’t do anything about it because my car isn’t in a certain part of the United States. If I don’t get this fixed soon the mechanic said my when could fall out of alignment and cause some serious damage to me or someone else.”

“The contact owns a 2006 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the contact heard a loud bang and scraping sound coming from the vehicle. The ABS and check engine warning lights were illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the control arm and suspension had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made not aware of the failure. The failure mileage was approximately 176,000.”

“I have a 06 sonata 2.4l that had rear control arms rotted out plus the subframe. And my esc light is on not really sure what to wit that. But my car is down now due to rear control arms needed replaced.”

“The contact owns a 2006 Hyundai Sonata. The contact stated that while making a turn at 10-15 MPH, the contact heard a loud bang and scraping sound coming from the vehicle. The contact pulled over and discovered that the rear crossmember had detached. The vehicle was towed to an independent mechanic, who diagnosed that the lower and upper control arm bolts were severely corroded; however, the contact was not yet informed of what needed to be replaced. The vehicle was not repaired. The vehicle had previously been repaired under NHTSA Campaign Number: 13V354000 (Suspension); however, the failure occurred. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.”

“The rear suspension became corroded and one of the coils or bars broke off while driving. After the coil from the suspension broke off, it punctured a tire, which blew while driving. Thankfully, I had just exited the interstate, otherwise this would've happened at high speeds. This is a known issue that has previously been reported in a recall (113). The vehicle is registered in Ohio and has been since 2014.”

“The contact owns a 2006 Hyundai Sonata. The contact stated while driving 25 MPH, the vehicle drove over a bump in the roadway and the steering wheel had to be turned all the way to the left to keep the vehicle going straight. The vehicle was taken to a non-Hyundai dealer who diagnosed that the cross member of the vehicle was entirely corroded, and the control arm had detached from the cross member. The contact stated that while checking the vehicle Carfax report, he became aware that the recall repair under NHTSA Campaign Number: 13V354000 (Suspension) had been completed on the vehicle prior to him owning the vehicle. The contact contacted Alexandria Hyundai (1707 Mt Vernon Ave, Alexandria, VA 22301) where the recall repair was completed, and was informed that an anti-corrosion inhibitor was sprayed on the cross member of the vehicle instead of replacing the cross member. The manufacturer was notified of the failure and advised the contact to take the vehicle to an authorized Hyundai dealer for diagnostic testing. The vehicle was not repaired. The approximate failure mileage was 127,314.”