2018 Hyundai Sonata power train problems

“I recently had the 9C2 Emissions recall update performed on my car, and since the update my car drives like total garbage after a cold start. It hesitates to accelerate, it bucks when trying to accelerate, and it’s to the point the engine is about to stall. I took it back to the Hyundai dealership and they said they are aware of the issue, but there is no fix from Hyundai at this time. This is a major safety concern, as the car barely wants to accelerate after a cold start. Please have Hyundai fix this safety issue.”

“Check engine light solid/engine failure while driving. 2018 Sonata SE purchased new in fall 2018. Around 50,000 miles started noticing oil level drop and had to add more before next scheduled change. Dealership service center said I just had to shorten the mileage between changes which didn't seem appropriate for a vehicle with 50,000 miles but I did. Continued to have oil consumption problem with no signs of leak, no burning oil smell or exhaust issues. Dashboard display would go off and when I immediately checked dipstick there was barely any oil so I'd add more then go in for full change. At 67,000 or so miles in June 2026, without oil display going off the engine light was now solid. Got to reputable service center near my home and oil was under a quart left yet the warning lamp hadn't gone off. They ran the engine error code P0304 and was misfire #4 cylinder and after compression test, #3 was very low and #4 very high. NOT drivable at that point then towed to dealership so yes, available for inspection by NHTSA at the dealership. For now they claim a 'tune up' is needed for spark plug replacement, valve cover gasket replace and fuel induction service…”

“Following completion of Service Campaign 9C2 (ECU software update, TSB 25-01-087H) at a Hyundai dealership, my 2018 Sonata immediately exhibited drivability changes that were not present before the service. Symptoms include altered shift timing, hesitation, and rougher throttle response — particularly noticeable during the first several minutes of driving. These symptoms began on the first drive after the recall update was applied and have been consistent since. The vehicle was returned to the dealership for inspection. No underlying mechanical issue was found, confirming the drivability change is directly attributable to the ECU software update. The vehicle has been maintained strictly per Hyundai's manufacturer-recommended schedule and had no prior drivability issues. I am aware that numerous other owners of Theta II-equipped vehicles (Sonata, Santa Fe, Tucson) have reported identical symptoms following 9C2. At least one dealership has reportedly acknowledged this as a known post-update issue that Hyundai is working to resolve. The altered throttle and shift behavior poses a safety concern, as unexpected hesitation during acceleration affects predictable…”

“The contact The contact stated that when taken the vehicle for a service campaign repair and shortly after went for recall r The vehicle does not run properly on cold starts, the RPMs increase rapidly and slow down, vehicle jerks forward once beginning to drive.. The vehicle does not have this issue once the vehicle is warm. The manufacturer was not notified of the issue. The approximate. Failure mileage was 47,575.”

“Engine blown out malfunction took two dealer Hyundai Folsom Lake stated rings are bad sludge buildup in engine and stayed at Hyundai motor America denied engine replacement due to knowledge under Theta two engine extended warranty settlement of 150,000 MI 15 years I'm still within warranty but are still being denied had numerous of issues with vehicle oil consumption knock knock sensor replace and other maintenance done since purchase vehicle brand new in 2018”

“I bought a 2018 Hyundai Sonata a few years back. No warranty. Used. 110,000 miles. A few short months after I purchased it, it stopped working. I took it back to the same dealership where I purchased it and they said they had to replace the coil packs and spark plugs and clean something in the engine out because there's a defect in the engine. I paid $500. Fast forward a few months later. Same thing happens. I take it to an auto repair shop because it's cheaper and the mechanic says he deals with these same issues with other customers who have similar year, make, and models. This pattern continues to this very day. It broke down while I was working my 2nd job. I have a daughter. She plays sports. I have a second job. I need this problem completely alleviated as quickly as possible. Like a lot of the American public, I don't have extra money to keep up with anything beyond the normal maintenance of my vehicle. I keep it up to date with all oil changes. What can you do to get me a vehicle I can trust and it not break down every couple months and cost $300-$600 each time? I don't have good credit (I'm working on that) I have medical issues that I have to visit my…”