2022 Hyundai Tucson Hybrid engine problems

“System/Component Failed & Inspection: The vehicle suffers from recurring failures across the engine, powertrain, electronic throttle control, and exhaust gas recirculation (EGR) control systems (DTCs P0524, P0642, P2118, P022100). The vehicle is fully available for inspection upon request. Safety Risk: While driving, the vehicle suffered a complete, sudden loss of motive power on an active highway entrance ramp. The engine stalled in moving traffic with zero throttle response, creating an immediate collision hazard before requiring a tow. Confirmation by Dealer: Technicians formally confirmed these defect patterns. In May 2026, diagnostics logged major engine and emission/EGR control codes, but corporate refused goodwill repair. In August 2026, the highway stall recurred. Diagnostics confirmed active low oil pressure and throttle failure codes, which the dealer resolved by applying 4 factory ECU software updates under TSB 25-01-010H. Service personnel explicitly confirmed these engine control issues are manufacturing defects, not wear-and-tear or mileage-related. Inspections: Inspected, diagnosed, and serviced by authorized dealership service department…”

“While driving my 2022 Hyundai Tucson Hybrid, the vehicle suddenly lost power, began shaking, and all warning lights illuminated at once. The car would not accelerate properly and became unsafe to operate in traffic. After pulling over and restarting the vehicle, the warnings cleared, but the issue has occurred more than once. It first occurred 3/25/26. The dealer was not able to reproduce the issue but found numerous faults and reset them. This is a serious safety concern because the vehicle can unexpectedly lose motor power while driving, creating a risk of collision. The problem is intermittent and unpredictable.”

“I am reporting a critical Exhaust Gas Recirculation (EGR) valve and electrical circuit failure on my 2022 Hyundai Tucson Hybrid. The failure resulted in the check engine light illuminating, diagnostic codes identifying an EGR system malfunction, and visible corrosion found within the EGR connector and extension harness. This component breakdown causes severe performance risks, risk of sudden loss of engine power, and compromises vehicle safety. Diagnostic & Technical Details: Error Codes Captured: Diagnostic trouble codes in the P0400 series (EGR system flow/circuit malfunction) along with connector/wiring degradation were confirmed during inspection. Root Cause & Symptoms: The failure stems from degradation and electrical shorting risks in the EGR valve assembly and its immediate wiring harness connection. Manufacturer Response & Escalation Denial: When addressing this failure, I discovered that Hyundai has acknowledged widespread EGR valve assembly defects, electrical short risks, and solder flux contamination issues across multiple model years and production lines (such as NHTSA Campaign 24V-308 and subsequent service campaigns like 9B3). However, Hyundai…”

“On XXX the vehicle lost motive power while my wife was accelerating to merge onto a highway with our two young children aboard. It would not accelerate and she was forced to pull over in an active merge area. Simultaneous warnings illuminated: Electronic Parking Brake, ESC, Forward Collision Avoidance, Blind Spot Detection, and hybrid system, with "Check Hybrid System" displayed. No crash or injury occurred, but loss of propulsion during a highway merge created serious collision risk. This is a recurring defect documented since early 2023: Hyundai's own Blue Link telematics auto-flagged an Engine Control System DTC on XXX; a jump-start was required XXX (dealer RO #XXX); check engine light and stored CAN-bus codes U100387, U100100, U004600, U010100 on 08/10/2023 (RO #XXX); and a September 2023 incident in which the center display shut off during reverse, disabling the backup camera. Hyundai performed Service Campaign 9B4 (BMS software update, DTC P1BB20, TSB 25-01-010H-1) on this VIN on XXX; the same failure category recurred 84 days later. The vehicle was towed to Safford Hyundai of [XXX] onXXX and has remained there 65+ consecutive days. The dealer replaced…”

“The contact owns a 2022 Hyundai Tucson. The contact stated that while driving, after an hour, the vehicle was shaking and shuddering abnormally and the vehicle lost motive power. The driver was unable to maintain a steady speed while driving the vehicle. The vehicle was making an abnormal sound while driving at 60 MPH, and the vehicle was struggling to accelerate. There were no warning lights illuminated. The blue link indicated that the failure was associated with DTC: P03600. The vehicle was taken to the local dealer, who was unable to retrieve a diagnostic trouble code. The vehicle was diagnosed as needing the fluid, tires, and brakes to be changed, and the low jack to be removed. The vehicle was not repaired. Another local dealer, Napleton Hyundai (4333 W Ogden Ave, Aurora, IL 60504) was contacted, but there was no response. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 48,000.”

“Car is a Gas Hybrid (not plugin). 3 occurrences over the last couple of months. Car emits a warning sound and a message on the dash says "Check Hybrid System. Stop Safely". Basically right after this message the car starts losing power and stops. Doesn't matter if on freeway or not. You need to find a place to pull over or you stop traffic wherever you are. Looks like Hybrid Battery is completely drained. Can not be re-created. Dealer has it now for the 3rd time. Dealer in the past have not been able to find cause/cure since this issue is not posting any errors to the onboard diagnostic system. Temporary 'fix' is to power off car, and power back on. Looks like this is a 'known' issue though as its being reported by quite a few people online.”