2008 Hyundai Veracruz service brakes problems

“ABS Anti-Lock Brake System Failure (ABS Control Unit) As seen in NHTSA CAMPAIGN [XXX], for newer year models, The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving. This recall should also include 2008-2010 Hyundai Veracruz's as the ABS Module is the same part number and can leak brake fluid. This can lead to serious injury or death as the car may not function as intended or catch on fire. I noticed a strong burning smell similar to burning toast when the car was dropped off at the shop. My Mechanics noticed my ABS Control Unit had liquid coming out of the poorly sealed module, and told me to report this to the NTSHA. The unit had to be replaced for about $3800. The first symptom is the ESC Light flashing while driving. Others include the AWD Light, Brake Light, ABS Light, and, Traction Control Lights. On many forums like the link shown below other people have experienced this issue on the 2008 Hyundai Veracruz as well. This indicate that the recall should be pushed to ALL Veracruz models. Hyundai should be responsible for the safety of all…”

“Component or System Failed or Malfunctioned: The ABS harness connecting to the ABS module is the primary culprit. Specifically, the top part of the harness is not adequately sealed, which has led to water ingress and subsequent wire shorting. Availability for Inspection: No, the ABS harness is available for inspection upon request. Safety Risk: The malfunctioning ABS harness poses a significant safety risk. When the ABS system fails, it affects braking performance, stability control, and traction control. This jeopardizes the safety of both the driver and other road users. Confirmation by Service Centers: While the issue was previously identified by the Hyundai Dealer it was attributed to a short in the Tow Hitch Wire. Unfortunately, the problem was not adequately resolved at that time. The recent appearance of the ESC Light, ABS Light, and Traction Control Light confirms that the issue persists. Inspections: The vehicle has not been inspected by the manufacturer, police, or insurance representatives specifically for this issue. However, the symptoms (warning lights) have been observed consistently during driving. Warning Lamps and Symptoms: ESC Light: Periodic…”

“TL* THE CONTACT OWNS A 2008 HYUNDAI VERACRUZ. WHILE DRIVING 5 MPH, THE ABS MODULE MALFUNCTIONED AND CAUSED THE VEHICLE TO CATCH FIRE. THE CONTACT NOTICED SMOKE UNDER THE HOOD OF THE VEHICLE AND FLAMES IGNITED FROM THE BATTERY. A POLICE REPORT WAS NOT FILED. THE FIRE WAS EXTINGUISHED BY ATTENDANTS FROM A NEARBY AUTO BODY SHOP. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DESTROYED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 144,000.”

“MY VEHICLE IS EXPERIENCING ALL OF THE ISSUES LISTED IN THE FOLLOWING CAMPAIGNS, YET, THE MANUFACTURER IS REFUSING TO COVER THE REPLACEMENT OF THE PART. 13V113000 09V122000 THE VEHICLE GETS STUCK IN DRIVE, OR PARK, AND CAN'T BE ADJUSTED WHEN THE BRAKE IS DEPRESSED. THE ESC STICKS ON RANDOMLY. I'VE REPLACE MANY, MANY BRAKE LIGHTS IN THIS VEHICLE.”

“BRAKE LIGHT, ABS AND ESC OFF LIGHT ON REPEATEDLY. BRAKE LIGHTS STOPPED WORKING. VEHICLE WOULD NOT SHIFY OUT OF GEAR. AUTO START STOPPED WORKING. HAD STOP LAMP SWITCH REPLACED, NOW SPEEDOMETER NOT REGISTERING AND ESC LIGHT FLASHING ON. THE BRAKE LIGHT, ABS AND ESC OFF LIGHT STILL REMAIN ON.”

“TRAVELING AT 55 MPH A WHIRLING NOISE STARTED UNDER THE HOOD ON THE DRIVERS'S SIDE. ABS,ESC,, CHECK ENGINE ,AND PARKING BRAKE LIGHTS CAME ON AT THE SAME TIME, THE SPEEDOMETER WENT TO O, AND THE CAR SHUT OFF. NEARLY REAR ENDED TWICE, INJURED , AND NEARLY STRUCK DOWN GETTING OUT OF THE CAR AND OFF THE HIGHWAY. COULD NOT GET THE CAR STARTED. HAD CAR TOWED. COLONIAL HYUNDAI OF DOWNINGTOWN, PA. DIAGNOSED THE CAR WITH A BAD ABS HYDRAULIC CONTROL ASSEMBLY. PART NUMBER 58910-3J 850. THE CAR COULD NOT BE MOVED UNTIL THE PART WAS INSTALLED. IT COST ME $2500. I REQUESTED AN INSURANCE CLAIM FORM, BUT WAS TOLD HYUNDAI MOTORS OR COLONIAL HYUNDAI WOULD NOT PAY FOR IT. CALLED HYUNDAI IN FOUNTAIN VALLEY CA. FILED A CLAIM: NUMBER 9841469. OBTAINED DIAGNOSTIC REPORTS AND REPAIR INVOICES FROM COLONIAL HYUNDAI. CAR HAS ONLY 30,000 MILES PURCHASED BRAND NEW.”