2008 Jeep Patriot fuel/propulsion system problems

“The vehicle stalls after a gas fill up. Daughter was stuck in traffic. No Power steering, brakes, etc. Started back up. very dangerous. This has happened after every fill up.”

“Car stalls after fill up. NUMEROUS online Jeep forums have noted this issue for years. There seems to be an issue with the “vapor canister”. Recall was apparently issued for 2011 model - but not older models. It is intermittent yet consistent problem over past few months. Please note that an Engine stall leaves steering wheel LOCKED and unable to maneuver car for a period until can restart. Can leave driver on a VERY DANGEROUS situation traveling at speed !”

“UNKNOWN After I fill up on gas at different stations I had the car sputter and die after filling up til the nozzle stopped itself went to go start the car the first time it happened I got maybe half a mile down the road and stopped at a light and the car died. The second time I was at another gas station and I forgot to shut the car off because it was freezing cold felt like a negative 10 I went to go leave and thought oh crap let me shut it off for a second so the gas would register faster of what I had then if I left it on. I went to go drive away then and the car wouldn’t move I thought great what could it be well I looked down and I wasn’t “on” so I restarted the car and I could tell the car started and I sat for a few and it died. I waited a few seconds and started it again and sat for a few and then was able to go about my business. The third time I filled up and didn't think anything of it because it had been awhile since it happened but I pulled out on the street and it was at a T intersection and I was coming up and to the left well when I turned I died and the light had changed to green I was barely able to make it into the turn lane from when I…”

“CAR STALLS WITHIN THE FIRST MINUTE OR SO OF DRIVING AFTER FILLING GAS TANK TO SHUTOFF. WHEN THE ENGINE DIES, SO DOES THE POWER STEERING, CREATING A VERY DANGEROUS SITUATION. HAPPENS CONSISTENTLY. BEGAN SEVERAL YEARS AGO BUT I LIVED WITH IT BY NOT FILLING TANK TO FULL. NOW MY SON DRIVES THE CAR, AND I AM CONCERNED THAT IT MAY HAPPEN WHEN HE IS DRIVING AND CAUSE AN ACCIDENT. THIS IS VERY DANGEROUS. MANY PEOPLE HAVE COMPLAINED ABOUT IT, AND NHTSA MUST DO SOMETHING ABOUT IT AND HOLD CHRYSLTER/JEEP RESPONSIBLE”

“EVERY TIME I REFILL MY TANK WITH FUEL, THE FIRST SEVERAL MINUTES OF DRIVING THE ENGINE WILL HESITATE AND ALMOST STALL (OR WILL STALL IF DRIVING AT SLOW SPEEDS). WHILE STOPPED IN IDLE, ENGINE WILL COMPLETELY STALL. ONCE SOME FUEL IS BURNED, THE ENGINE WILL NO LONGER STALL. THIS ISSUE HAS BEEN ONGOING FOR YEARS.”

“APPROXIMATELY 12/2018 I HAD TO HAVE MY GAS TANK REPLACED DUE TO A FAULTY ROLLOVER VALVE/FLAPPER/INLET CHECK VALVE LOCATED IN THE GAS TANK. I AM NOW HAVING THE SAME PROBLEM WITH THE NEW GAS TANK. THE COST TO REPAIR THIS PROBLEM IS WELL OVER $1400 AND TO HAVE TO DO THE SAME REPAIR TWICE IS UNTHINKABLE. THIS HAS TO BE SOME SORT OF SAFETY ISSUE AS WELL, BECAUSE IF THESE VALVES/FLAPPERS ARE SUPPOSED TO EXPEL AIR FROM THE SYSTEM, COULDN'T THIS BE HARMING MY VEHICLE MORE AND/OR CAUSE PRESSURE TO BUILD IN THE TANK? THERE WAS TSB 14-001-09 REV A ISSUED. CHRYSLER ADMITS THIS IS A BIG PROBLEM AND HAS RECALLED A BUNCH OF JEEPS, DODGES, AND SOME CHRYSLER TOWN & COUNTRY VANS. HOWEVER, MY MAKE AND MODEL (08 PATRIOT) IS NOT COVERED UNDER THE EXTENDED WARRANTY THEY ISSUED FOR THE GAS TANKS.”