2018 Jeep Wrangler power train problems

“The contact owns a 2018 Jeep Wrangler. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 23V116000 (Power Train); however, the failure persisted after the recall repair. While driving 15 MPH, the instrument cluster failed to display the gear that the transmission was shifted to. Several unknown warning lights were illuminated, and the vehicle failed to turn off. The contact stalled the engine and waited for the vehicle to shut off. The vehicle was taken to the dealer, who determined that the instrument cluster had damaged the transmission and CAN C bus connector. The dealer replaced the instrument cluster, transmission, and CAN C bus connector, but the instrument cluster again failed to display the transmission gear. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 54,000.”

“FCA US LLC is actively violating the intent of Safety Campaign 23V-116 by refusing to cover out-of-pocket consequential transmission damages. FCA’s own Part 573 Defect Report explicitly admits that the defective clutch pressure plate causes extreme friction, overheating, and fracturing capable of damaging the transmission case and nearby internal components. The vehicle operated under these defective parameters prior to the recall execution, subjecting the transmission internals to progressive thermal fatigue and severe structural vibration. This directly induced a premature internal mechanical failure less than 9,000 miles after the recall was performed. When a reimbursement claim was submitted for this consequential damage, Jeep Customer Care explicitly denied the claim under a corporate case file, stating the transmission components "are not covered under the recall repair," completely ignoring FCA's own federal defect acknowledgments. I am requesting a federal investigation into FCA’s systemic refusal to cover consequential powertrain failures caused by this safety defect.”

“report to the dealer that my 2018 jeep has recall for clotch overheating and vehicle can catch on fire , and it has been 3 years with no respond or completion or the job been done , feel kind of scared for the safety of me and my family every day driving ah vehicle can catch on fire . please help us to resolve this situation thanks”

“manual transmission pops out of 2nd gear during deceleration, (grinding not all the way in nuetral) untill put back in gear again. getting worse over time. found alot of same thing on internet, some getting 2 ,3, or 4 transmisions under warrenty”

“The contact owns a 2018 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, there was an abnormal burning odor inside the vehicle. No warning lights were illuminated. In addition, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to the dealer, and the contact was informed that parts for a recall repair might have been replaced with defective parts. The contact was informed that there was no failure and the vehicle was released; however, the failure reoccurred. The vehicle was taken back to the dealer, where it was confirmed that the clutch was slipping. The contact was informed that the clutch needed to be adjusted. The vehicle was repaired, but the failure reoccurred. The vehicle was taken to the dealer, and the contact was informed that the failure was because the contact was changing gears at 2,000 RPM and the gears should be shifted at 2,500 RPM. The vehicle was taken to an alternative dealer where the contact was informed that the recall repair was completed incorrectly. The contact was informed that the recall repair needed to be performed a second time. The vehicle…”

“Recall 19A was a full clutch assembly replacement on January 2024 at 60,000 miles. I purchased the vehicle in January 2025 with 64,000 miles. I have owned the jeep for 1 year and 8 months. I now have 78,000 miles. Service transmission light comes and goes if the vehicle cools down the light goes off and drives normal. When the service transmission light is on the clutch is overheated and slips I can not move the vehicle out of 1st gear. I drove it to a dealer and they state I have a bad clutch it is overheating. I do not believe I should pay for a clutch after a brand new clutch kit was installed 17,000 miles ago.”