2021 Kia K5 fuel/propulsion system problems

“I am filing a safety complaint regarding my Kia K5 because I am concerned about a potentially dangerous mechanical defect. I purchased this vehicle used from CarMax approximately two years ago. Within the first 30 days of ownership, the steering wheel began shaking. CarMax repaired the problem at no cost after ordering a replacement part. Approximately two weeks ago, the steering wheel began shaking again. The problem has now progressed to the vehicle shaking, feeling as though it is skidding or slipping, and failing to accelerate properly. The check-engine light is illuminated. I contacted Kia regarding recall SC250 and was told that my vehicle does not qualify. I am concerned because my vehicle is now experiencing symptoms that I believe warrant investigation into whether they could be related to the defect addressed by this recall. I am requesting that NHTSA investigate whether my vehicle may have an unresolved or related safety defect, and whether other vehicles excluded from the recall could be experiencing similar problems. I am concerned about the risk of losing acceleration while driving, potentially putting me and other motorists in danger. I can…”

“2021 Kia K5 99K1ZRECALL Gas tank expanded and deformed the body, noticeable under back seat. Risk of gas leak or fire Kia of Mckinney service center has vehicle unrepairable SC356 KIA has case # 26282908 No symptoms, driver complained stopping was jerky CAN'T FIX CAR AND WON'T REPLACE IT.”

“Vehicle experienced a severe engine misfire (P0302), rough running, and loss of power while driving. Dealership confirmed the Purge Control / PCV valve failed (replaced under Recall SC356 / 25V-794), but charged out-of-pocket for the Cylinder 2 ignition coil that failed as a direct result of the PCV valve failure. The Dealership replaced the Purge Control/PCV valve at this time - the recall was not resolved until this time - I wasn't even aware of this recall until this incident. This ocurred on XXX and as a result I was stranded 1500 miles from home in [XXX] (I live in [XXX] and was driving the vehicle to my son at the University of XXX in [XXX]. The car was running fine until I stopped briefly in [XXX] and when I started the car, the engine light came on and the car's engine started sputtering and losing power as I was driving. Due to the fact that I was not in the vicinity of any Kia Dealerships or any open mechanics as it was Labor Day, I somehow managed to drive the car all the way to [XXX] as this was the closest dealership (over 120 miles away from where I was when the engine light came on). Once I arrived in [XXX], I checked into a hotel. I then…”

“I am reporting a violation of the National Traffic and Motor Vehicle Safety Act by Ball Kia (National City, CA). The dealer tried to deny service for recall 25V794000 (SC356) for a melted, leaking fuel tank, fabricated a false diagnostic narrative of road impact to exploit me, and tried to charge $3,000 out-of-pocket for a federally mandated free repair.My vehicle has a severe fuel leak from a compromised fuel tank. Ball Kia service refused the recall, claiming "external aesthetic factors" or "road debris impact" caused it, and pressured me to tow it away.Using my military infantry experience in mechanical damage assessment, I inspected the vehicle in the service bay. I verified there is absolutely no puncture, tear, scrape, or kinetic impact on the fuel tank assembly. The dealer pointed to a split in the fuel tank protector panel, but a professional assessment shows this is false. The plastic protector panel failed due to extreme thermal exposure; the expanding tank pressed it against the hot exhaust, causing it to melt and tear under heat/pressure, not a kinetic strike.The tank itself is structurally melted and deformed with zero signs of road impact. This…”

“Recall NNK post-repair failure. Dealership: Kia of Valdosta (RO# XXX). After ECU update NNK-02-0118, my K5 suffered a severe loss of acceleration and torque. The car cannot safely merge on highways. The dealer’s own live scan data sheet proves that at 4,997 RPM under full load, the Turbo Recirculation (Dump) Valve reads "OFF". The factory tool key explicitly states (OFF = Open). The service manager is misreading the tool, claiming "OFF" means closed, and refuses to fix it. The boost gauge only rises under heavy floor acceleration, proving an uncalibrated boost leak. I have uploaded a photo of the technician's data sheet directly to the attachments and will also drop link to videos of my car in normal and sport mode. I have also opened Kia Corporate Case #XXX. I demand a corporate Regional Technical Manager review this data and authorize a Turbocharger Recirculation Valve (RCV) and Wastegate Adaptation Relearn at an alternate dealer...... 1. [XXX] 2. [XXX]”

“My car is losing power upon acceleration causing a loss of power upon take off upon taking off and when gears are shifting. Told by dealer it is a problem with fuel injection. Replaced several coil packs and spark plugs on my own. Dealer repair shop had my car for 4 days for the fuel talk and valve issues and did not repair anything. Losing power when I drive in traffic and on highway is a huge safety issue causing loss of power when at highway speeds. I plugged in a code reader bought by myself which is telling me it’s coil packs. We have replaced several with no luck. There is a smell of fuel and with all the other fuel system recalls and after reading other complaints on this site that sounds similar, I fear this is a safety issue with the vehicle. They checked my fuel tank and valve but didn’t replace either. I believe this is related to all the other fuel system recalls and should be repaired free of charge by dealer as a dysfunctional fuel problem as nothing we’ve done to repair with the code reader has fixed this issue. I fear a loss of power of fire caused by the mounting fuel system issues of these issues have caused the issue I’m having. Please look…”