2019 Kia Optima Plug-in Hybrid engine problems

“Car smelled of what seemed like motor oil while driving. Parked, saw white smoke, and confirmed an engine fire. I was clearly in life threatening danger, especially with a full tank of gas. Fire developed rapidly into a roaring blaze. Entire front of car melted. Car is currently being investigated by manufacturer and cause is unknown. No warning lamps illuminated.”

“VEHICLE SHUT OFF WHILE DRIVING AT 40MPH, ENGINE SEIZED ,WILL NOT CRANK .SUSPECTED CONECTING ROD BEARING FAILURE UNDER SAFETY RECALL SC200, I CALL KIA 18003334542 DENIED RECALL REPAIR AND BEARING CLEARANCE TEST STATING VEHICLE IS REBUILT TITLE. FEDERAL SAFETY RECALL CANNOT BE DENIED DUE TO REBUILT TITLE PER NHTSA .REQUESTING RECALL REMEDY.”

“The vehicle experienced a sudden and severe loss of engine power while being driven on the interstate at highway speeds. The vehicle lost the ability to accelerate normally beyond approximately 60 mph, the Check Engine Light began flashing rapidly, and the vehicle entered “Limp Home Mode.” This sudden loss of power occurred in heavy traffic and created an immediate risk of a high-speed rear-end collision. The vehicle was subsequently inspected by an authorized Kia dealership service center. Diagnostic testing confirmed DTC P1326 (Knock Sensor Detection System). The dealership performed the manufacturer’s Bearing Clearance Test (BCT), and the dealership paperwork documents a “NO PASS BCT” result. The dealership paperwork also documents that Service Campaign SC340 (Theta II 2.4L GDI ECM Software Upgrade) was performed on the vehicle. Despite the documented P1326 condition and the manufacturer’s “NO PASS BCT” result, the dealership is refusing to provide the engine replacement as a covered repair and has instead quoted approximately $9,000 for the engine replacement. I am requesting that NHTSA review this matter because the vehicle experienced a sudden loss of…”

“On December 26, 2023, this vehicle received a complete engine assembly replacement at an authorized dealership under a manufacturer warranty repair order. Following the engine overhaul, the vehicle developed a severe, raw gasoline smell entering the passenger cabin through the climate control AC vents while sitting at an idle.The vehicle was brought back to Kia Store East on September 10, 2026, specifically to report this volatile safety issue. On September 17, 2026, the dealership technician explicitly duplicated and confirmed the raw fuel odor coming from the engine area in writing. Despite confirming the gasoline smell, the dealership is refusing to perform a manual high-pressure fuel system pressure-drop test to isolate the physical vapor leak. Instead, they have listed a high-pressure Fuel Pipe Assembly (Part # 35305 2GGA0) on a customer-pay estimate paired with an unrelated $1,819.12 timing cover oil seal repair.The dealership is claiming the failure is out of warranty and is holding the vehicle while forcing daily rental car fees onto me, refusing to isolate the active fuel leak unless I authorize the out-of-pocket repair. The vehicle currently sits…”

“While driving, my vehicle suddenly began shuddering and shaking. The vehicle lost power and would not accelerate properly. I had to press the brake pedal unusually hard. After parking, the vehicle would not move properly in reverse or drive. I turned the vehicle off and restarted it, and it moved only a short distance before shuddering again and losing power. The engine was making a loud buzzing or scooter-like sound. The vehicle became undrivable and had to be parked. I am concerned about a potential safety defect involving sudden loss of power while driving.”

“The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 200,000.”