2013 Kia Optima engine problems

“The contact owns a 2013 Kia Optima. While driving at 65 MPH, the vehicle lost motive power but continued to drive under reduced power, with the check engine warning light illuminated. The failure nearly caused a crash. The vehicle was taken to O'Reilly's, where three knock sensor codes were retrieved. The vehicle was then taken to the dealer and was repaired under NHTSA Campaign Numbers: 23V652000 (Service Brake, Hydraulic), 22V093000 (Fuel System, Gasoline), and 22V560000 (Structure). The manufacturer was notified of the failure by phone. The failure mileage was approximately 125,055.”

“Despite documenting this catastrophic internal mechanical destruction, the authorized franchise dealer has issued a written directive instructing the driver to operate this structurally compromised vehicle on public roads for a 1,000-mile oil consumption test with explicit instructions not to add, check, or have anyone service the engine oil level. Operating an engine running dry with verified cylinder wall gouging and unstable timing chains creates an imminent, severe safety hazard for the occupants and other motorists, including sudden highway engine lockup, loss of power steering, or vehicle fires. The vehicle underwent Safety Recall Campaign SC147 in 2017, which carries a court-mandated Lifetime Warranty Extension on the block for core failures. The dealership is forcing an unsafe vehicle modification and dangerous roadway test to evade standard warranty coverage processing. A complete 11-invoice history proves this defect originally manifested and was logged by a technician at 96,738 miles while fully inside the standard factory coverage window.”

“The contact owns a 2013 Kia Optima. The contact stated that while driving or while the vehicle was parked, there was an abnormal fuel odor inside the vehicle. The vehicle was leaking fuel from the high-pressure pipe leading to the fuel pump. The contact associated the failure with NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine); however, VIN was not included in the recall. The dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not included in recall. The manufacturer was made aware of the failure but offered no assistance. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 250,000.”

“On July 14, 2026, the vehicle's engine was replaced by an authorized dealership under an official Kia recall. On August 16, 2026, while driving on the highway, heavy smoke suddenly began emitting from the engine compartment. When attempting to slow down, the braking system suffered a total loss of power and failed completely. To stop the vehicle, it had to be steered into the highway median to intentionally scrape against it to force a stop. Immediately upon exiting the vehicle, heavy flames were observed under the engine compartment before completely engulfing the front of the car. The fire department extinguished the fire, and the vehicle is a total loss.”

“My 2013 Kia Optima was running fine at 65 mph when suddenly the engine stalled. I then coasted to the shoulder and smelled burning plastic. As soon as I opened the hood the engine started being consumed in fire, it quickly went to a very large engine fire that consumed the front half of the car. There were no other vehicles involved with this incident. Vehicle is a total loss.”

“The vehicle is experiencing sudden engine stalling while in motion, a known safety hazard. Despite a documented maintenance history with no issues, the dealer (Bayside Kia) is attempting to deny a Theta II Settlement claim by shifting the narrative to 'engine sludge,' which only appeared as a symptom in June 2025( Walmart oil change) alongside engine performance issues. The vehicle has active codes P0014 and P0017, which are secondary symptoms of the internal bearing wear and metallic debris contaminating the oiling system. KDS Diagnostic tests showed Cylinder 1 at 0.16mm (approaching the 0.20mm failure limit). This clearance proves the connecting rod bearings are worn and reaching the failure threshold; this mechanical wear is the root cause of the engine's inability to operate safely. The presence of metallic debris in the oil is the definitive signature of the Theta II manufacturing defect. Furthermore, the dealer acted in bad faith by attempting to charge for Airbag repairs (Codes B1346/B1481) that are covered under the 15-year Clock Spring Warranty Extension (CS1102). The dealer has dismissed my qualifying maintenance documents, claiming they are 'not…”