2001 Kia Rio electrical system problems

“IT IS DIFFICULT TO ENTER THE CAR WITH THE KEY AND WHEN I PULL THE DOOR HANDLE THE LOCK DROPS DOWN TO THE CLOSE POSITION AND I CAN'T GET OUT THIS HAPPENS ON THE DRIVER'S SIDE AND THE FRONT PASSENGER SIDE,I HAVE TO HOLD THE LOCK ON THE UP POSITION WITH A PIECE OF METAL OR LEAVE THE REAR DOORS UNLOCKED IN CASE I HAVE TO JUMP OUT..THIS CAR IS A LEMON I HAVE REPLACED SENSORS ALTERNATOR, STARTER, AC PARTS AND MANY OTHER PARTS THE ONLY THING GOOD IS THE TRANSMISSION AND THE ENGINE... *JS”

“CONSUMER COMPLAINT: ODI CASE NUMBER: 10136024 COMPONENT: WHEELS GAS IGNITION? YOU TELL ME? WHEN ARE THESE PEOPLE GOING TO BE COMPENSATED FOR THEIR LEMONS KIA-2001 DETAILS: DT: THE CONSUMER WAS INVOLVED IN AN ACCIDENT AND A TIRE BLEW OUT. AFTER THE VEHICLE STOPPED SPINNING, THE CONSUMER GOT OUT OF THE VEHICLE AND IT BURST INTO FLAMES, THE FIRE DEPARTMENT CAME AND THEY SAID FIRE STARTED FROM HEAT OF POWER EQUIPMENT AND THE IGNITION BURNED. THIS HAPPENED ON AUGUST 6, 2005. *AK THE CONSUMER STATED SHE WAS NOT INFORMED ABOUT THE RECALL REGARDING THE WHEELS. THE CONSUMERS DAUGHTER COMPLAINED THAT THE STEERING WHEEL VIBRATED FROM THE TIME THE VEHICLE WAS PURCHASED. THE SAME TIRE THAT THE BLEW OUT WAS THE SAME ONE THAT HAD BEEN REPLACED NUMEROUS TIMES. *JB OCCURRENCES: 1 INJURIES: 0 FAIL DATE: 08/06/2005 DEATHS: 0 DATE ADDED TO DATABASE: 9/9/2005 [FILE] YOUR OWN COMPLAINT ON THIS MODEL CAR. *TR”

“THIS IS A KIA RIO 4 DR. 2001 ..WITH 12,000 APROX MILES WHEN THE ECU FUSE BROKE, ON HWY 127 NEAR DEATH VALLEY ..HAD TO GET TOWED INTO MY DESTINATION.IT TOOK ABOUT 5 DAYS TO GET A PART FROM CALIF,UPS TO ME FROM A FRIEND, I CHANGED THE FUEL LEVEL SENSOR,,WHICH I THOUGHT WAS THE PROBLEM...THE NEAREST KIA DEALER WAS 80 MILES AWAY IN LAS VEGAS,,,I LATER DISCOVERED THAT IT WAS A BLOWN ECU FUSE..NOT A SENSOR..I THEN DROVE THE CAR APTROX 500 MILES BACK TO CALOIF,WHEN IT BLEW AGAIN ON THE HWY 15 NEAR FONTANA,...I TOOK THE CAR TO KIA DEALER IN ONTARIO CALIF, THEY ONLY DID 2 WARRANTY ITEMS ON THE CAR.#1 WAS AN UPGRADE OF THE ECM.AND #2 REPLACED A FUEL DIST SENSOR////THE DEALER SAID IT WOULD FIX THE FUSE ISSUE,,,WHICH I TOLD THEM UP FRONT. THEY RETURNED THE CAR I WAS GOING BACK TO NEVADA IT BLEW A FUSE ECU ON HWY 15 HAD IT TOWED HOME AGAIN,,,,THE DEALER PICKED UP THE CAR FROM RIALTO 10 MILES AWAY FROM MY PARENTS....THEY HAD THE CAR 4 DAYS AND TOLD ME IT WOULD TAKE APROX 600$ TO GET UNDER THE DASH WHERE THEY BELIEVE THERE IS A SHORT THAT IS CAUSING THIS ECU TO BLOW,,I HAD THE CAR RETURNED ON MY AAA AGAIN TOOK IT FOR A SECOND OPINION,,,AGAIN THEY ALSO SAID IT COULD BE UNDER…”

“DASH LIGHTS WILL NOT WORK. COME OFF AND ON. CHECK ENGINE ALSO COMES OFF AND ON. REPAIRED TWICE, STILL COMES ON AFTER SHORT DRIVE. WARNED BY POLICE FOR DASH LIGHTS. CAR WILL BE TOWED BECAUSE UNSAFE DRIVING CONDITION. CAN NOT AFFORD COSTLY REPAIR TO WIRING SYSTEM AT THIS TIME. *TR”

“01 RIO IS A LEMON & SAFETY HAZARD. MANY MAJOR REPAIRS DONE INCLUDING THE TIMING BELT & VALVES REBUILT, NEW COOLING SYSTEM, BOTH CONTROL ARMS & BOOTS. WHEEL DEFECT RECENTLY RECALLED CAUSED EXCESS WEAR/ TEAR ON CONTROL ARMS, BOOTS, ALIGNMENT, TIRES, COSTING THOUSANDS OF AVOIDABLE REPAIRS. FUEL INTAKE DID COME LOSE, NEARLY CAUSING AN ENGINE FIRE DUE TO DEFECTIVE PART WHICH WAS RECALLED. IT CONTINUOUSLY MISFIRES, ENGINE KNOCKS, STALLS. ECM WAS RECALLED BUT DIDN'T FIX THE PROBLEM. REPLACED SPARK PLUGS & WIRES (3 TIMES IN 6 MONTHS), IGNITION COIL, SENSORS (OXYGEN, KNOCK, CRANKSHAFT, TEMP). IT STOPS FOR A 1-2 DAYS, THEN COMES BACK. ANNOYING & DANGEROUS. ALSO HAS ACCELERATION PROBLEM. AT TIMES, IT WON'T GO OVER 40 MPH & ALSO ACCELERATES BY ITSELF. BRAKES HAVE COMPLETELY FAILED, THOUGH THERE'S NO CRACK IN THE LINE, NO LEAKING FLUID. THE CAR IS A COMPLETE LEMON. ONLINE, THERE ARE HUNDREDS OF SIMILAR COMPLAINTS. DEALERS ARE AWARE BUT CONVENIENTLY CAN'T SEEM TO DIAGNOSE THE PROBLEMS ESPECIALLY MISFIRING. CONSUMERS GET NICKEL & DIMED DOING NEEDLESS REPAIRS THAT DON'T FIX THE PROBLEM. THE OPTIMA HAD SIMILAR PROBLEMS W/CRANKSHAFT POS. SENSOR WHICH WAS RECALLED, BUT DEALER…”

“2 YEARS AGO I NOTICED THAT THE CAR DOES NOT WANT TO START WHEN IT HAS NOT BEEN DRIVEN FOR A LONG PERIOD OF TIME (12 HRS). I TOOK THE ENGINE COVER OFF AND TRIED TO START THE CAR WITH THE REMOTE STARTER. I NOTICED THAT THERE WERE SPARKS COMING FROM THE DISTRIBUTOR AND THE SPARK PLUG WIRES. TOOK CAR IN TO DEALER AND ALL WAS DONE WAS CHANGED SPARK PLUG WIRE AND PROBLEM STILL HAPPENS. DEALER JUST WANTS TO CHANGE THE WIRE AND PLUGS. *JB”