2004 Kia Sedona wheels problems

“I HAVE A 2004 KIA SENDONA LX VAN AND THE WHEEL BARRINGS ARE BAD I FIXED IT ONCE ALREADY A MONTH AGO AND IT IS ALREADY BROKEN AGAIN BOTH TIMES IT COMPLETELY FELL APART IN TO LITTLE PEICES WHEN I TOOK THE WHEEL OFF.”

“THE WHEEL BEARINGS DISINTEGRATED AND CAUSED THE WHOLE HUB TO COME OFF. LUCKILY WE WERE RIGHT AROUND THE CORNER FROM OUR DESTINATION AND WEREN'T GOING VERY FAST. *TR”

“TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A LOUD CRACKING NOISE. A FEW MOMENTS LATER, HE HEARD A LOUD EXPLOSION. THE CONTACT PULLED OVER AND NOTICED THAT THERE WAS A HOLE IN THE REAR PASSENGER SIDE HUB AND THE BEARING WAS MISSING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 05V232000 (WHEELS). THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.”

“VEHICLE: 2004 KIA SEDONA AT 47K MILES ROARING NOISE COMING FROM REAR-END. NOTIFIED KIA SINCE THERE WAS A RECALL ON CERTAIN 2004 MODELS BUT THEY SAID MY VEHICLE WAS NOT PART OF THE RECALL...GO FIGURE. I HAD MY LOCAL AUTO REPAIR SHOP REPLACE BOTH INNER AND OUTER WHEEL BEARINGS ON THE REAR AXLE. THEY SHOWED ME THE OLD BEARINGS WHICH WERE RUSTY AND HAD PITS. IT APPEARS THAT ALL 2004 MODELS SHOULD HAVE BEEN INCLUDED IN THIS RECALL. *TR”

“TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH SHE HEARD A ROARING NOISE COMING FROM THE WHEELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE SHE WAS INFORMED SHE NEEDED NEW WHEEL BEARINGS ON ALL FOUR WHEELS. THE MANUFACTURER WAS NOTIFIED AND SHE WAS INFORMED HER VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V232000, WHEELS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 90,000.”

“I HAD THE FRONT WHEEL BEARINGS AND HUBS REPLACED AT 65,000 MILES ON MY 2004 KIA SEDONA UNDER WARRANTY DUE TO PLAY IN THE HUB. LAST MONTH DURING A BRAKE INSPECTION I WAS INFORMED THAT THEY ARE BAD AGAIN THE VEHICLE NOW HAS 106,000 MILES. THIS IS A POTENTIAL HAZARD AS WHEN THEY FAIL COMPLETELY THE WHEEL WILL FALL OFF POTENTIALLY CAUSING A SERIOUS ACCIDENT. I BELIEVE THIS TO BE A DESIGN FLAW SINCE THIS ONLY VEHICLE I HAVE OWNED IN 30 YEARS THAT NEEDED BEARINGS REPLACED EVEN ONCE MUCH LESS TWICE IN 100,000 MILES. JUST TO LET YOU KNOW THE REAR BEARING WERE REPLACED TWICE ALREADY UNDER WARRANTY ONE TIME UNDER A RECALL AND ANOTHER TIME AS A RESULT OF ANOTHER BRAKE INSPECTION. *TR”