2016 Kia Sedona structure problems

“2016 Kia Sedona with power sliding doors. Both rear power sliding doors fail to completely latch upon closing. Doors make loud clicking sounds while attempting to close and require manual pushing to latch. Kia of Attleboro diagnosed and confirmed in writing that both rear door roller arm assemblies are completely missing the roller, and that this condition is contributing to the latching failure. Both power sliding door motors and rear door latches also need replacement. This is a safety hazard as the doors may appear closed but are not fully latched, posing a serious risk of doors opening while driving, particularly with children as passengers. The condition has been confirmed in writing by a Kia dealership. Kia Motors America issued Warranty Bulletin WTY019 in March 2021 specifically extending coverage for this exact latching condition on 2015-2017 Sedona vehicles to 15 years/unlimited miles. The covered components (motors and latches) have been approved for warranty replacement. However, Kia America has denied coverage for the roller arm assemblies despite their own dealer's written confirmation that these parts are directly contributing to the covered…”

“My White Kia Sedona Van's paint is flaking and peeling off all around the vehicle. This is not due to poor car of the vehicle or accident due to making contact with any other vehicles or objects. It is literally just falling off of the vehicle. It started about a year ago and is getting significantly worse.”

“Vehicle's paint has been peeling off or delaminating specifically near ALL the window glasses. The worse affected area which has started getting rust spots. Below and above the sliding door glasses have started peeling off and starting to show primer or under layer as well as below the back door window. I have only gotten quotes for temporary solution which would be to paint current affected areas. But after researching many articles online, this seems to me a common issue people have been complaining not only on these areas my vehicle has. So I am thinking this might happen to other areas of the vehicle which would require a full repaint job.”

“Our Kia Sedona had the cooling fan harness negative Cable melt and caused making our engine overheat. When we took our vehicle to get serviced they told us that the cooling fan harness melted and then it's a common problem with kias. They fixed the pigtail cooling fan harness but are cooling fan does not turn on anymore and they said that it is now an electrical issue and this was from a Kia dealership in Dodge City Kansas. They recently did a recall on sliding doors because they weren't shutting all the way and it worked for exactly one day after the recall and now it's back to not shutting and making a really loud noise when it attempts to shut. When this happens we can't lock our doors because the doors won't lock when doors open and we have to constantly shut off our interior lights so that they don't stay on because the doors don't shut. We've notified the Kia dealership that have done our recall on it and told them that it didn't fix it but they refuse to make it right. We only have 106,000 MI I've got a new cooling fan resistor and put it in and a new pigtail harness and put it in but the cooling fan is still not turning on the low speed and the air…”

“BOTH SLIDING DOORS OPEN UP WHEN GOING DOWN THE ROAD AND BOTH SLIDING DOORS WILL NOT SHUT ALL THE WAY UNLESS U PUSH ON THEM HARD TO SHUT BUT THEY WILL STILL OPEN UP REGARDLESS”

“The sliding power doors no longer function properly. The door closes, and immediately unlatches. The door can be forced closed, but can and does then unlatch while driving. Kia of Cape Coral confirmed the doors are not latching properly due to the door motors. Kia agrees the doors are covered, but refuses to remedy the issue until the motor is unable to move the doors at all.”