2015 Kia Soul engine problems

“Sudden engine misfire and stall in major metropolitan area in high traffic. Diagnosis from my mechanic was failed valve and complete loss of compression to 2nd cylinder. Symptomatic of repeat catalytic converter issues leading to engine damage. Catalytic converter has been replaced twice-- once out of pocked and once under extended warranting for SC176/NHTSA 19V-120000 at a kia dealership. Engine light turned on just minutes before failure. I am now beyond the extended 150,000 warranty-- engine failed at 167,000.”

“RECALL SC176 INCOMPLETE- WHILE DRIVING IN AN UNINCORPERATED AREA IN [XXX] ([XXX] IN [XXX] COUNTY) THE VEHICLE SUDDENLY LOST ENGINE POWER AND DUE TO THE SUDDEN LOSS OF ENGINE POWER THE VEHICLE WAS DIFFICULT TO STOP ON A DANGEROUS CURVE. THE VEHICLE WOULD NOT START BACK UP. THE CRUVE WAS SITUATED IN SUCH A MANOR THAT IT WAS UNSAFE TO TRY TO PUSH IT INTO THE SIDE AS IT WAS A STEEP DITCH LEAVING THE VHICLE COMPLETELY DISABLED IN THE COMPLETE DARK. EVEN WITH THE FLASHERS ON OTHER MOTORISTS INCLUDING A SEMI TRACTOR TRAILER NEARLY CRASHED INTO THE DISABLED VEHICLE MULTIPLE TIMES. WHILE ESCAPING THE DANGEROUS SITUATION ON FOOT I NOTICED THE MUFFLER WAS EMMITING SMOKE AND A STRONG ODOR. I WAS ABLE TO RETAIN THE SERVICES OF A LOCAL TOWING COMPANY TO PROVIDE IMMEDIATE EMERGENCY RESPONSE WHERE THEY HAD TO USE MULTIPLE UNITS WITH CONES AND AMBER LIGHTS AND FLAGMEN WITH STROBES TO SET UP A SAFTEY ZONE TO PROTECT ONCOMMING MOTORISTS WHILE THEY CLEARED THE IMMEDIATE SAFTEY HAZARD. THAT WEEK I HAD A LOCAL MECHANIC SHOP CHECK ON THE NO START CONDITION. THEY REMOVED, CHARGED, AND BENCH TESTED THE BATTERY FINDING IT TO PERFORM AT AN ACCEPTABLE AMPERAGE. UPON INSPECTING THE NO…”

“My husband purchased our 2015 Kia Soul 1.6L GDI in 04/18. It was recalled under the NHTSA 19V120 & Kia SC176 in 04/19. The recommended fix? Update ECU Logic. Completed: 04/24/19. Check engine light came in 07/19. My appointment in 08/19, at #1 Cochran Kia showed a P0455 large leak code. Per invoice, manual leak test found no leak, but found gas cap not installed correctly after adding fuel, codes were cleared, & road test performed; "mileage in": 65582, "mileage out": 65583. Was that a road test? In 01/20, the Soul at the dealer for check engine light; P050A code was found & there was no resolution. They sent me home with the check engine light on. Auto Zone recommended catalytic cleaners. I used these because the illuminated check engine light created stress & still does. Auto Zone found another P0420 code for replace catalytic converter on 08/21. More cleaners. 01/22 Auto Zone found replace ignition coils & spark plugs. 04/22 extended warranty expire At dealer on 01/23, for a check engine light. A catalytic converter replace was recommended for $2,199.95. I could not afford that. More cat cleaner. Auto Zone found P0420 code on 06/23. Cat cleaner did not work.…”

“The contact owns a 2015 Kia Soul. The contact received notification of NHTSA Campaign Number: 20V750000 (Engine). The vehicle was taken to the dealer, and the engine was inspected and it was determined that there was no failure with the vehicle. The contact was charged for the diagnostic test. While driving at an undisclosed speed, the vehicle went into LIMP Mode and failed to accelerate above 20 MPH. The check engine warning light was illuminated. The vehicle was taken back to the dealer a second time, but no failure was found. The vehicle was then taken to Pep Boys, who diagnosed that the engine was leaking oil onto the exhaust system and catalytic converter. The vehicle was taken back to the dealer a third time, where it was determined that the catalytic converter was clogged and the diagnostic trouble codes were cleared. The dealer informed the contact that the recall repair would not be performed until the rod bearings had failed. The vehicle later caught on fire near the catalytic converter and the contact extinguished the fire. The manufacturer was notified of the failure by phone and a case was filed. The failure mileage was approximately 145,000.”

“The contact owned a 2015 Kia Soul. The contact stated that while driving approximately 40 MPH, there was smoke coming from the exhaust, with an abnormally loud popping sound coming from the vehicle. The vehicle was pulled over to the side of the road, and the contact exited the vehicle and became aware that there was a line of fire on the main road leading to the bottom of the vehicle. The contact stated that a week prior to the failure, there was an abnormal burning odor coming from inside the vehicle. The contact called the Emergency Services, and the Fire Department arrived and extinguished the fire. A fire report was filed. The vehicle was towed to a tow yard and was deemed a total loss. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.”

“Dealer refusing to honor open recall remedy for SC200 / NHTSA 20V750000 on 2015 Kia Soul VIN [XXX], approx 100k miles. Recall shows "no unrepaired recall found" on NHTSA VIN lookup, but KSDS update and engine bearing test were never performed. Kia of Cheyenne states: 1) must pay for recall because update not done, 2) must pay for unrelated repairs first, 3) must provide all oil receipts, 4) will not perform free remedy. Second dealer Fort Collins Kia service phone rings no voicemail. Request NHTSA reopen recall and enforce free remedy per 49 USC 30120.”