2016 Lincoln MKC engine problems

“My 2016 Lincoln MKC with a 2.0L EcoBoost engine experienced coolant intrusion into cylinder 3, leading to engine misfire and check engine light to turn on. The dealership confirmed the issue for $176.55 and recommended a full long block engine replacement, estimated at over $11,000. This failure occurred at 98,000 miles. Two weeks before this, the check engine light illuminated and we took it to a repair shop where we paid $628 to repair the purge valve and fuel pressure sensor, while it was most likely this coolant intrusion both times! Ford and Lincoln (including concierge) have refused any assistance in this matter. The local dealership has also said that they cannot help us with any of the cost. I've found this to be a very well documented problem/engine design failure, Including HTSA ID Number: 10162062 Manufacturer Communication Number: TSB 19-2172 entitled Components: ENGINE AND ENGINE COOLING The TSB acknowledges a design-related coolant leak into the engine cylinders that can cause white smoke, misfire, rough running, and warning lights. Ford’s recommended repair is to replace the long block assembly. In addition, this appears to be the exact issue…”

“I have Coolant intrusion in cylinder #2 91000 miles this should be a recall it's a problem that's well documented There's a recall for the back up camera hope the camera can see through the white smoke!”

“The contact owns a 2016 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed that the supercharger-A and the under boost needed to be replaced. The vehicle was repaired; however, the check engine warning light was illuminated again. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.”

“When driving you could smell fumes, it would jerk, and kick in and out of gear and would have no heat. Coolant was always low with no visible leaks to the mechanic.”

“The contact owns a 2016 Lincoln MKC. The contact stated that while starting the vehicle, the vehicle was shaking, and the check engine warning light was intermittently illuminated. The contact stated that her brother had replaced the spark plugs and ignition coils. The vehicle was taken to the dealer, who determined that there was coolant intrusion into the engine. The contact was informed that the spark plugs and coils needed to be replaced with OEM parts, and the turbocharger, purge valve, vacuum line, long block, and fuel pressure sensor needed to be replaced. The contact stated that her nephew replaced the spark plugs and ignition coils with OEM parts, and AAMCO replaced the fuel pressure sensor; however, the failure recurred. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 158,000.”

“At 85,000 miles I was experiencing a grinding noise coming from my front end when making sharp turns to left or right. Took car to my mechanic immediately for diagnosis. They found the motor mounts and rear differential is binding and close to failure. My mechanic contacted FOMOCO to see about a replacement for the rear differential and was told that there were not any available due to a REDESIGN of the product. He was asked to check back in two weeks! Two weeks w/o my transportation! I replaced the motor mounts, (85Kmi?) After researching on line, several ford & lincoln sites the problems I am experiencing are not unique or infrequent on Lincolns and ford Edges. It would seem to me that these problems are frequent enough to have the manufacturer ininitiate a recall on these products! My mechanic also works on our Sherriff department vehicles and their Ford Edge units are experiencing same problems. I would hope these problems will initiate an investigation into this matter!”