2007 Nissan Frontier fuel/propulsion system problems

“1. The fuel pump and fuel sensor suddenly stopped working without prior notice while driving down the road. 2. Sudden loss of power while driving creates a dangerous situation. 3. An independent service center stated that "Nissan Corp. had a recall on fuel pump sensors. 4. The fuel pump and fuel sensor were replaced. 5. I called Nissan Corp, but they said that vehicle did not qualify for a recall of the fuel sensor.”

“JUST FINISHED READING THROUGH 23 PAGES OF COMPLAINTS GOING BACK TO 2008 REGARDING FAILURE OF THE FUEL LEVEL SENDER UNIT--PRIMARILY ON 2007 NISSAN FRONTIERS. MINE FAILED AT APPROXIMATELY 69,000 MILES IN FEBRUARY 2020, WITH THE SAME SYMPTOMS THAT NUMEROUS OTHER OWNERS EXPERIENCED: UPON FILLING THE TANK, THE GAUGE WOULD DROP TO ZERO, THE LOW FUEL LIGHT WOULD ILLUMINATE AS WOULD THE CHECK ENGINE LIGHT--MY CODE READER DISPLAYED A 463 CODE, FUEL LEVEL SENSOR FAILURE. THE GAUGE WOULD GRADUALLY GO TO FULL, AND OPERATE NORMALLY UNTIL IT READ JUST UNDER HALF FULL, WHEN IT WOULD AGAIN DROP TO ZERO. WHILE THE FAILURE FELL WITHIN THE 72000 MILE EXTENDED WARRANTY, THE YEAR DIDN'T, SO NISSAN REFUSED TO MAKE THE REPAIRS. I HAVE TO JOIN THE CHORUS OF 2007 FRONTIER OWNERS WONDERING WHY IDENTICAL 2006 AND 2008 MODELS--WITH EXACTLY THE SAME SENDER--WERE SUBJECT TO A SAFETY RECALL, BUT NOT THE 2007S. IT'S AN OBVIOUS SAFETY ISSUE, OR THE FUEL GAUGE SENDER'S PERFORMANCE WOULDN'T BE INCLUDED AS AN ERROR CODE IN THE OBD II SYSTEM. HOW ABOUT WORKING THE PROBLEM, NTSHA? IT'S NOT TOO LATE!”

“THERE IS A KNOWN PROBLEM WITH THE FUEL SENDING UNIT FOR FRONTIERS ABOUT THIS AGE. NISSAN EXTENDED THE WARRANTEE A FEW YEARS AGO, BUT IT WASN'T LONG ENOUGH TO COVER THE DEFECT. NOW THE SENDING UNIT NEEDS TO BE REPLACED FOR THE FUEL GAUGE TO WORK, AND THE WHOLE GAS TANK NEEDS TO BE DROPPED TO DO IT. NISSAN OUGHT TO COVER THIS KNOWN ISSUE WITH A FULL RECALL, NOT JUST AN EXTENDED WARRANTEE.”

“CONTINUES AIRBAG PROBLEMS. FROM THE SATELLITE AIRBAG SENSORS BEING RUSTY AND WATER INTRUSION TO THE OCCUPANT AIR BAG SENSOR. I HAVE ALSO HAD CONTINUOUS MISFIRES THAT HAVE CAUSED THE CATALYTIC CONVERTER ON BANK 1 TO FAIL”

“TL* THE CONTACT OWNS A 2007 NISSAN FRONTIER. THE CONTACT STATED THAT THE FUEL GAUGE DID NOT REFLECT THE ACTUAL AMOUNT OF FUEL IN THE TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE FUEL LEVEL SENDING UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.”

“MY FRONTIER WAS INVOLVED IN A FUEL LEVEL SENSOR RECALL IN 2010 AND WAS NEVER REPLACED.THE CEL CAME ON TODAY(10/17/2018).I CALLED MY LOCAL DEALER AND THEY SAID THE WARRANTY ON THAT PART WAS INCREASED 72;000 MILES OR THREE YEARS.SO AS OF TODAY IT IS EXPIRED.I THOUGHT IF A PART WAS UNDER RECALL IT WAS FOR THE LIFE OF VEHICLE. I WORKED AT THIS DEALERSHIP FOR OVER TWENTY YEARS AND NEVER HEARD OF ANYTHING LIKE THIS.IF A PART IS DEFECTIVE DOES IT MATTER WHEN IT FAILS?”