2001 Nissan Pathfinder suspension problems

“The contact owns a 2001 Nissan Pathfinder. The contact stated while driving approximately 35 MPH, the contact was attempting to use her brakes to slow for traffic and was unable to stop. The contact had to depress the brake pedal to the floorboard to get the vehicle to stop. The contact stated that prior to the failure her ABS warning had been illuminated for a long period of time prior to the failure. The contact drove the vehicle to an independent mechanic where it was diagnosed that due to a significant amount of rust, the front suspension and struts and brake pads, and rotors had to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 11V244000 (Steering and Suspension). The work had been previously completed by a dealer. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 142,000.”

“FAMILY CAR;2001 NISSAN PATHFINDER, WE GOT IN THE TRUCK AND DROVE ABOUT 250 FEET TO THE STOP SIGN. I STOP. AS I STARTED MOVING AND SUDDENLY I HEAR A POP LOUD SOUND FROM ENGINE COMPARTMENT AND MY STEERING GOT HARD AND DIFFICULT TO STEER AND A GRINDING SOUND AS YOU TURN THE STEERING. DROVE BACK TO THE HOUSE SLOW AND PARK. OPEN THE HOOD AND I SEE THE STRUT TOWER UNDER NEATH THE BRAKE MASTER CYLINDER, THEN I LOOK BETWEEN LEFT SIDE (DRIVERS) TIRE THE STRUT TOWER JUST RIPPED FROM THE FACTORY WELD. MY FAMILY IN THE CAR WHEN THIS OCCUR. WHAT IF THIS OCCUR WHILE ON THE HIGHWAY AT HIGHER SPEEDS. MY TRUCK ONLY HAS 106523 MILES AND WAS SCHEDULED FOR A PA INSPECTION.”

“DRIVER'S SIDE STRUT TOWER HAS RUSTED TO THE POINT WERE THE TRUCK WILL PASS VA STATE SAFETY INSPECTION. THERE WAS A RECALL PERFORMED BY SEVERAL YEARS AGO BY NISSAN FOR THE RUST ISSUE ON BOTH INNER WHEEL WELLS AND STRUT TOWER AREA.”

“THE SUB-FRAME/CRADLE 54400-0W00 ON THE PASSENGER SIDE IS ROTTED OUT TO THE POINT THAT IT WILL NOT PASS A PA STATE INSPECTION. THIS WAS FOUND BY MY MECHANIC WHILE HE WAS REPLACING THE FRONT ROTORS AND BRAKES. MY MECHANIC HAS ORDERED A NEW SUB FRAME + BOLTS TO REPLACE THE ROTTED OUT SUB-FRAME. I WONDER HOW MANY OTHER SUB-FRAMES ARE ROTTED OUT ON PATHFINDERS FROM 1996 TO 2004 WHICH IS WHEN NISSAN USED THIS PARTICULAR PART. MY CONCERN IS IF THIS PART FAILS COMPLETELY WHAT WILL HAPPEN??? I HAVE RESTRICTED DRIVING MY PATHFINDER UNTIL THE NEW PART IS INSTALLED. I THINK SOMEONE SHOULD LOOK INTO THIS PROBLEM, BECAUSE WHEN IT FAILS AND IT WILL SOMEONE WILL GET HURT OR EVEN KILLED? THE CONTROL ARMS MOUNTED TO THIS PART WHICH CONTROLS STEERING. THIS PART PLUS LABOR WILL COST ME ABOUT $1500.00.”

“THERE IS AN EXCESSIVE AMOUNT OF RUST ON THE VEHICLE INCLUDING THE WHEEL WELL, DOOR JAMS, FLOOR BOARD, AND FRAME. I WAS ALMOST UNABLE TO RECEIVE A REPLACEMENT WINDSHIELD BECAUSE THE FRAME IS RUSTING OUT. I PURCHASED THE VEHICLE IN THE NORTH THEN MOVED SOUTH AND THE PROBLEM HAS GROWN WORSE. THE COMPARTMENT THAT IS HOLDING THE SPARE TIRE UNDER THE VEHICLE IS RUSTING OUT AS WELL. THIS COULD POTENTIALLY BECOME A SAFETY PROBLEM IF THE SPARE TIRE SEPARATES FROM ITS SUPPORTS WHILE OPERATING ON A ROADWAY. RUST HAS BEEN AN ONGOING PROBLEM WITH THIS VEHICLE WITH NO SPECIFIC START DATE NOR END DATE.”

“DRIVER SIDE FRONT STRUT TOWER MADE A LOUD "POP" SOUND WHEN DRIVING. BOTTOM PORTION OF STRUT TOP CRACKED THROUGH. STRUT TOWER BEARING NOW MOANING WHEN TURNING, OUT OF GIMBLE.”