2002 Oldsmobile Alero engine and engine cooling problems

“I WAS ON MY WAY TO WORK ON 3/13/11 DRIVING MY 2002 OLDSMOBILE ALERO, AND MY CAR STARTED FILLING UP WITH BLACK SMOKE. I IMMEDIATELY PULLED OVER AND GOT OUT OF MY CAR, I SUDDENLY SAW FLAMES INSIDE OF MY VEHICLE . I CALLED THE FIRE DEPARTMENT AND BY THE TIME THEY PUT OUT THE FIRE MY CAR WAS TOTALED. *TR”

“CAR WILL NOT START .... SOMETIMES AFTER IT HAS BEEN DRIVEN IT WILL NOT START BACK SOMETIMES IT WILL TAKE AROUND 30MINS TO START BACK OTHER TIMES LONGER, THE LENGTH OF TIME IT HAS BEEN DRIVEN WHEN IT DOES THIS VARIES SOMETIMES ITS VERY SHORT DISTANCE OTHERS IT IS A LITTLE LONGER. THE CAR TURNS OVER BUT WILL NOT START. IT DOES NOT DO THIS ALL THE TIME BUT YOU NEVER KNOW WHEN IT WILL DO THIS. WE HAVE HAD THE FUEL PUMP CHANGED RECENTLY AND THE BATTERY IS FINE. *TR”

“THE EVENT IS UNEXPECTED, THERE IS NOTHING DEFINITIVE THAT LEADS UP TO THE FAILURE. THE FAILURE IS THAT THE ENGINE SHUTS DOWN WHILE DRIVING. IT HAS HAPPENED 4 TIMES IN THE LAST NINE MONTHS. ONCE IT WAS ABLE TO BE RESTARTED AFTER JUST A FEW MINUTES; ANOTHER TIME I HAD TO WAIT ABOUT 45 MINUTES TO RESTART IT THEN IT SHUT DOWN AGAIN AFTER DRIVING 12 MILES DOWN THE ROAD. EACH TIME IT WAS TAKEN TO A GARAGE AND PLACED ON THE DIAGNOSTIC, IT DOESN'T SHOW A PROBLEM EXISTS, THEREFORE, TO DATE, NO REPAIRS HAVE BEEN MADE SINCE NO ONE KNOWS WHAT THE PROBLEM IS . THERE HASN'T BEEN ANY INJURY AT THIS TIME DUE TO THIS PROBLEM, BUT IF THIS CONTINUES A SERIOUS OCCURRENCE IS INEVITABLE; I.E. LOSING POWER WHILE DRIVING DOWN THE HIGHWAY AT 65MPH. *TR”

“THE LOWER INTAKE MANIFOLD GASKET NEEDS TO BE REPLACED IN MY CAR 2002 ALERO WITH 67,500 MILES, COME TO FIND OUT GM KNOWS ABOUT THIS AND IT IS A COMMON REPLACEMENT, DESIGN FLAW WITH GM VEHICLES EVEN THE REPAIR SHOPS HAVE KNOWLEDGE ABOUT THIS. IS THERE A R-EMARKET REBATE FOR THIS PROBLEM. IT WILL VCOST ME ABOUT 700 TO FIX THE PROBLEM. *TR”

“CAR WAS BEING DRIVEN WHEN A LOUD EXPLOSION CAME FROM THE ENGINE COMPARTMENT. THE CAR THEN IMMEDIATELY CUT OFF AND HAD TO BE TOWED IN FOR SERVICE. UPON INSPECTION, IT WAS FOUND THAT THE TIMING CHAIN HAD BROKE AND THAT THERE WAS OTHER INTERNAL VALVE AND ENGINE COMPONENT DAMAGE. THE ENGINE IS A 2.2L GM MOTOR THAT WAS RECALLED FOR SATURNS, AND OTHER VEHICLES, BUT NOT THE ONE WE OWN WHICH IS AN OLDSMOBILE ALERO. *TR”

“I HAVE HAD MY 2002 OLDSMOBILE ALERO SINCE 2002. WITHIN SIX MONTHS OF HAVING THIS CAR THE IGNITION SWITCH WENT BAD AND WAS UNABLE TO START THE CAR AND IT HAD TO BE REPAIRED. THIS WAS REPAIRED BY THE DEALER THAT I PURCHASED IT FROM BECAUSE THE COMPANY THAT WAS IN CHARGE OF MY EXTENDED WARRANTY WENT BANKRUPT. SINCE THEN I HAVE HAD TO PAY TO REPLACE A GASKET IN THE ENGINE THAT KEEPS ENGINE COOLANT AND ENGINE OIL FROM MIXING TOGETHER BECAUSE THE GASKET THAT WAS MANUFACTURED WITH THE CAR WAS NOT THE RIGHT THICKNESS. (SINCE THIS IS A KNOWN DEFECT BY MECHANICS WHY WASN'T THIS RECALLED OR A SERVICE BULLETIN INITIATED?) I CONTINUE TO HAVE PROBLEMS WITH THE DRIVER DOOR CONTROL PANEL THAT CONTROLS THE WINDOWS AND THE SIDE MIRRORS AND WINDOW LOCKS. THE WINDOWS IN MY CAR CAN ONLY BE CONTROLLED BY THE DRIVER BECAUSE THE WINDOW LOCK IS STUCK IN THE "ON" POSITION. I HAVE ALSO HAD PROBLEMS WITH THE WINDOWS FALLING DOWN INTO THE DOOR AND HAVE HAD ONE WINDOW REPLACED IN DECEMBER 2007 BUT NOW IN SEPTEMBER 2008 THE PASSENGER WINDOW IS EXPERIENCING THE SAME SYMPTOMS AND NOW WILL HAVE TO REPLACE THIS WINDOW AS WELL. RIGHT NOW THE MOST ANNOYING THING ABOUT THIS CAR IS THE TURN SIGNALS.…”