2003 Saab 9-3 suspension problems

“I HAVE ALSO BEEN HAVING ISSUES WITH THE FRONT PASSENGER SIDE SUSPENSION. I WOULD HAVE TO CHECK MY RECORDS, BUT I BELIEVE IT STARTED WHEN THE CAR HAD ABOUT 25K MILES ON IT. THE SPRINGS ARE STILL IN TACT, BUT I WOULD NOTICE A VERY LOUD CREAKING NOISE GOING OVER SPEED BUMPS IN PARKING LOTS, ESPECIALLY IN COLD TEMPERATURES. I BROUGHT IT TO THE ATTENTION OF THE DEALERSHIP WHILE IT WAS STILL UNDER WARRANTY AND THEY DID NOT OFFER ANY RESOLUTION. AFTER READING THE LARGE NUMBER OF COMPLAINTS OF BROKEN SPRINGS, I NOW KNOW WHY I AM AFRAID TO DRIVE THIS CAR ON THE FREEWAY. I WOULD REALLY LIKE TO GET THIS FIXED UNDER A RECALL BEFORE IT CAUSES AN ACCIDENT AND SOMEONE GETS SERIOUSLY INJURED OR KILLED. *TR”

“DRIVING DOWN STREET AT 30 MPH. LEFT SIDE FRONT SPRING BROKE. SPRING STUCK OUT AND SHREDDED TIRE. LEFT SIDE OF CAR DROPPED, WHICH THEN CAUSED RIGHT SIDE SPRING TO COME OFF AND CUT RIGHT SIDE TIRE. HAD TO REPLACE BOTH FRONT SPRING / STRUT ASSEMBLIES, AND REPLACE 2 TIRES. RESEARCHED PROBLEM, FOUND THAT GM MANUFACTURED THESE CARS IN 2003 - 2006 AND WAS OFFERING A WARRANTY TO FIX THIS PROBLEM. MY SAAB IS SEVERAL MONTHS PAST THE WARRANTY DATES BUT NOT THE MILEAGE LIMIT. HOWEVER, MY UNDERSTANDING IS THAT THE ORIGINAL PARTS WERE FAULTY OR DEFECTIVE. VERY DANGEROUS, AS IF CAR WERE TRAVELING FASTER IT COULD HAVE BEEN A SERIOUS ACCIDENT. I WOULD HOPE GM WOULD CORRECT OR PAY FOR A TRUE SAFETY ISSUE. *TR”

“THIS IS ON A 2003 SAAB 9-3 2.0T LINEAR MODEL. THERE WERE NO INJURIES THIS TIME BUT THE POTENTIAL IS VERY MUCH THERE. MY WIFE WAS PULLING OUT FROM A STOP LIGHT AND HEAR A LOUD POP FOLLOWED BY A LOUD GRINDING NOISE. SHE PULLED OFF IMMEDIATELY. WHEN I ARRIVED ON SCENE, I FOUND THAT THE DRIVERS FRONT WHEEL WAS PUSHED UP INTO THE WHEEL WELL. WHEN I REMOVED THE TIRE I FOUND THAT THE SPRING HAD BROKEN IN TWO (THE BOTTOM LAST RING BROKE OFF) AND HAD DROPPED DOWN TO WHERE THE JAGGED END (STILL ATTACHED/WRAPPED AROUND THE SHOCK) WAS POKING INTO THE TIRE. IT HAD LEFT A RELATIVELY DEEP GOUGE ALL THE WAY AROUND THE TIRE. I AM SURE I DON'T HAVE TO EXPLAIN TO YOU WHAT COULD HAPPEN IF THE SPRING WERE TO BREAK ON THE INTERSTATE AT 70MPH AND PUNCTURE THE TIRE. I AM QUITE CERTAIN THAT IF MY WIFE WOULD HAVE KEPT DRIVING ANY DISTANCE THAT THE SPRING WOULD HAVE DUG ITS WAY THROUGH THE SIDE WALL AND PUNCTURED IT. REMEMBER, WE CANT ALWAYS JUST PULL OFF THE INTERSTATE OR STOP AT THE DROP OF A HAT. IF YOU HAVE EVER DRIVEN THROUGH ATLANTA YOU WILL KNOW THIS TO BE TRUE ;) ANYWAY, WENT DIGGING ON THE INTERNET TRYING TO PURCHASE REPLACEMENT SPRINGS AND FOUND OUT THAT SAAB HAD ISSUED A…”

“NO EVENTS LEADING TO FAILURE. PASSENGER FRONT SPRING BROKE AT 71,000 MILES. BROKE PREVIOUSLY AT 35,000 MILES. CURRENT BRAKE AT 71,000, BROKEN SPRING DUG INTO PASSENGER FRONT TIRE AND PREVENT THE CAR FROM STEERING TO THE LEFT. SPRINGS WERE REPLACED BY THE DEALER AFTER THE 35,000 MILE FAILURE. SPRINGS AND STRUTS WERE REPLACED WITH AFTERMARKET PARTS AFTER THE 71,000 FILE FAILURE. *TR”

“TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 40 MPH SHE HEARD A LOUD GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE SWAY BAR FAILED BECAUSE OF THE RIGHT FRONT COIL SPRING. THE MANUFACTURER TOOK A REPORT. THE MANUFACTURER WANTED TO OFFER $100.00 TOWARDS THE COST FOR REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 83,000.”

“RETURNED FROM 2 WEEK VACATION WHERE CAR WAS PARKED IN AN OUTDOOR AIRPORT PARKING LOT. WHEN CAR WAS PUT INTO REVERSE TO BACK OUT OF PARKING SPACE, EXTRA GAS WAS REQUIRED TO START MOVEMENT, THEN LOUD BANG / POP AND THE CAR STARTED TO MOVE. (SOMETIMES AFTER A RAIN, THE DISK BRAKES SEEM TO RUST / WELD TO THE ROTORS AND REQUIRE EXTRA EFFORT TO BRAKE LOOSE. BUT THIS BANG / POP WAS LOUDER THAN NORMAL.) STARTED TO DRIVE OUT OF PARKING LOT, THEN ONTO STREET TO GET ONTO INTERSTATE. SMELLED RUBBER BURNING ODOR. OTHER DRIVERS INDICATED WHITE SMOKE COMING FROM RIGHT WHEEL WELL AREA. STOPPED TO INVESTIGATE AND FOUND RIGHT FRONT SUSPENSION SPRING BROKEN AND CUTTING A GROOVE IN THE SIDE WALL OF TIRE. CAR HANDLED NORMALLY, SO WE WERE GLAD WE HADN'T ENTERED INTERSTATE AND GOTTEN UP TO HIGHWAY SPEED. CAR TOWED TO MECHANIC. HE SAID ONLY RIGHT SIDE HAD PHYSICALLY BROKEN, BUT FELT THE LEFT SIDE WAS ABOUT TO BREAK ALSO. HE REPLACED BOTH LEFT / RIGHT STRUTS, SPRINGS, BRACKET, SUPPORT STRUTS, SWAY BAR LINKS AND RIGHT FRONT TIRE. *TR”