2003 Subaru Forester fuel system, gasoline problems

“TL* THE CONTACT OWNS A 2003 SUBARU FORESTER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE DURING COLD WEATHER, AN ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE FAILURE WOULD ONLY OCCUR IN TEMPERATURES BELOW 25 DEGREES. THE VEHICLE WAS TAKEN TO NEIL HUFFMAN SUBARU DEALER LOCATED AT 4916 DIXIE HWY, LOUISVILLE, KY 40216 WHO TIGHTEN AND RE-CLAMPED THE FUEL LINES BUT THE FAILURES CONTINUED TO OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TT *TR”

“IN VERY COLD TEMPERATURES THE INTERIOR OF MY VEHICLE IS OVERCOME WITH FUEL FUMES. IT HAPPENS AT IDLE AND LOW SPEEDS, DOES GO AWAY ONCE WE ARE DRIVING FOR A FEW MINUTES OVER 30 MPH. IT IS SO BAD WE HAD TO DRIVE WITH WINDOWS OPEN IN 5 DEGREE WEATHER. DEFINITELY COMING IN THROUGH THE HEAT VENTS, HOWEVER, SHUTTING THE HEAT OFF DID NOT ELIMINATE THE PROBLEM. THIS IS MY FIRST WINTER WITH THE CAR AND DIDN'T HAVE THIS HAPPEN UNTIL THE LAST FEW DAYS, WHEN THE TEMPS HAVE BEEN CONSISTENTLY BELOW 30 DEGREES F. I'VE READ NUMEROUS OTHER COMPLAINTS OF THIS, NOT SURE WHY THERE IS NO RECALL/SERVICE BULLETIN BUT WOULD LIKE TO KNOW THE SOLUTION TO THE ISSUE. IT CAN'T BE SAFE TO BREATHE THESE FUMES! WOULD LIKE TO KNOW THE SOLUTION TO THIS PROBLEM, AS WE OTHERWISE LOVE THIS VEHICLE! *TR”

“NOTICED THE SAME PROBLEM LAST YEAR ALSO AT ABOUT 134000 MILES. WHEN THE OUTSIDE TEMPERATURE DROPS BELOW 20 DEGREES WOULD BE MY BEST GUESS, THE WHOLE CAB OF THE CAR FILLS WITH GASOLINE FUMES. PRETTY POWERFUL SMELL. I NOTICE ONLINE IN MANY, MANY PLACES THAT SUBARU IS HAVING THIS ISSUE. THEY ARE ONLY FIXING WRX MODELS UNDER A RECALL. THAT IS MY UNDERSTANDING. UNFORTUNATELY, I DO NOT HAVE A WRX. I WILL PAY TO HAVE THIS FIXED, THOUGH SUBARU SHOULD STEP UP TO ALL MODELS WITH THIS VERY DETRIMENTAL ISSUE. THE DEALER IS ACTING A LITTLE SUSPICIOUS DENYING THEY KNOW ABOUT THE PROBLEM. SEEMS LIKE THEY SHOULD KNOW ABOUT ALL ISSUES THAT ARE SO PROMINENT ON THE INTERNET. MOST ARTICLES POINT TO FUEL LINES AT INTAKE MANIFOLD ARE FAILING. FAILING WOULD DEMAND TSB. *TR”

“DURING COLD WEATHER, (LATEST INCIDENT OCCURRED AT 15 DEGREES F), THERE IS A STRONG FUEL ODOR INSIDE THE VEHICLE WHILE THE VEHICLE IS RUNNING COMING FROM THE AIR VENTS INSIDE THE VEHICLE. AFTER STOPPING THE VEHICLE INSIDE OUR GARAGE THE STRONG FUEL ODOR CONTINUES UNTIL GRADUALLY LESSENING. A VISUAL INSPECTION DOES NOT REVEAL AN OBVIOUS FUEL LEAK. OTHER SUBARU MODELS WERE RECALLED FOR A SIMILAR PROBLEM AND AN ONLINE SEARCH SUGGESTS THIS IS NOT AN ISOLATED EVENT TO MY PARTICULAR VEHICLE. *TR”

“WHEN THE OUTSIDE TEMP DROPS BELOW 15 DEGREES FAHRENHEIT THERE IS A STRONG SMELL OF GASOLINE IN THE PASSENGER COMPARTMENT UNTIL THE ENGINE WARMS UP. TURNS OUT ITS FROM LEAKING FUEL LINES UNDER THE HOOD. THIS IS A KNOWN COMMON PROBLEM BY SUBARU WITH SEVERAL OF THERE CARS. *TR”

“VERY STRONG ODOR OF GASOLINE IN THE CABIN RIGHT AFTER STARTUP AND THROUGHOUT SHORT TRIPS, ESPECIALLY WITH HEATER ON. SEEMS TO HAPPEN MOST OFTEN WHEN OUTSIDE TEMPERATURES ARE NEAR OR BELOW THE FREEZING MARK. DID NOT EXPERIENCE BEFORE THIS WINTER, NOW OCCURS DAILY. PLEASE INVESTIGATE THIS PROBLEM BEFORE SOMEONE GETS HURT OR KILLED! IF SUBARU KNOWS THAT THERE IS A SAFETY PROBLEM WITH THE FUEL SYSTEM, OWNERS SHOULD NOT HAVE TO PAY FOR REPAIRS. *TR”