2012 Subaru Impreza electrical system problems

“The fan controls in the center of the dash failed. Fan speed 1&2 work, but 3&4 do not. After pulling the center dash controls out, I found that the plug connecting the fan speed controls to the wiring harness was burnt. This is a concern cause it could have burned other components or caused a fire.”

“HVAC plug pigtail Blower motor resistor Heater control harness Is available for inspection HVAC electrical plugin was badly burned and melted causing risk of fire Summer months created dangerous interior temperatures Winter months & inclement weather created physical distress- & created dangerous vision restrictions/blockage because unable to use defroster Dangerous cab temperatures, limited or blocked vision through windshield created physical distress and distraction for me thus others and property were at elevated risk Yes confirmed by garage. No inspection performed. No warnings available. There are 2 separate incidents: July 2023/august 2023 September 2024/april 2025”

“The contact owns a 2012 Subaru Impreza. The contact stated that while driving approximately 30-40 MPH, the vehicle lost power steering functionality and was driven with manual steering. The failure occurred while driving at various speeds. The contact stated that approximately four days after the first failure, the steering wheel failed to move. Additionally, the vehicle was losing oil and one quart of oil had to be added every month. The contact stated that the power steering, ABS, TPMS, transmission automatic transmission fluid (ATF), and 4-WD failure warning lights were illuminated. The passenger occupant sensor chimed for the passenger to secure the seat belt consistently even though the occupant was seated with the seat belt buckled securely. The contact who is a certified mechanic had replaced the rack and pinion. The contact noticed that the threads on the tie rods were close in proximately risking the chance of damaging the tie rods. The ABS module had been replaced. The contact believed that the engine needed to be replaced but the engine was not replaced. The manufacturer was made aware of the failure and opened a case. The manufacturer confirmed…”

“The Airbag warning light has been lit within the dashboard. The front passenger seat airbag is faulty and is not able to correctly sense when a passenger is within the seat or not, which disables the airbags. This can be deadly to the passenger if in an accident. The issue seems to be in the ODS passenger seat mat that determines when the airbag is active or not. If moisture is able to get within the mat, then it can short the circuit and cause airbags to not deploy. My car was "supposed" to already been fixed with the issue in 2015 on the recall #WQT55, NHTSA Campaign 15V419000, but I don't believe the underlying issue was fixed correctly or the same part has failed again. Looking further into recalls, the exact same issue is happening again with Subarus with #WRA-24 and NHTSA campaign 24V227. The dealer has asked me to pay over $1700 on to replace this part. Subaru America should fully cover the cost of any Passenger ODS issue especially when there have already been two recalls with the exact same issue.”

“The AC unit suddenly shutoff and there was a burning smell while I was driving. It turns out that the connector on the back of the climate control unit had either drawn too much current, or the resistance was too high, and the connector had started burning. Fortunately, the melted plastic interrupted the electrical connection, and the fire had went out on its own. It looks like this is not an isolated incident, and several others have dealt with similar when looking online.”

“Brake Lamp Switch failed in 2018 - we diagnosed the issue, based partly on information from other Subaru owners who had the same problem, and replaced the switch. Since that time, the brake lights have worked fine. We reported this in a letter to Subaru after their recall for the brake lamp switch replacement in 2019. They refused to pay for the part as we no longer have the receipt (not having a crystal ball, we couldn't see any reason to keep it for more than a year in 2018). We did not contest this - in fact, I had merely asked, in my letter, that they note that the part had already failed and been repaired in their records - however, they continue to flag the car as an open safety recall and insist that we bring the car in to replace a switch that no longer needs replacing. I am filing this complaint in the hope that an official record of the incident will fix the records on our car, as their constant recall notices are becoming increasingly more insistent and annoying, and they have also inaccurately noted it as an open recall at the DMV.”