2016 Subaru Outback power train problems

“While driving the 2016 Subaru Outback, the vehicle experienced a sudden, catastrophic failure of the Continuously Variable Transmission (CVT). The transmission completely failed, resulting in an immediate and dangerous loss of propulsion while operating the vehicle. This created an immediate safety hazard for myself, my toddler and other drivers on the road, as the vehicle could no longer maintain speed or accelerate safely to clear traffic. A certified repair facility diagnosed the issue as a complete internal mechanical failure of the transmission, requiring a total replacement at an estimated cost of roughly $11,000. This generation of Subaru CVTs has a well-documented history of premature, catastrophic mechanical failure, which Subaru of America has previously acknowledged via past warranty extensions. The sudden loss of power caused by this engineering defect poses a severe and ongoing safety risk to consumers. [XXX]”

“My 2016 Subaru Outback CVT transmission has exhibited an intermittent jerking and grabbing sensation when accelerating from a stop, worse when cold, since at least February 2023. This is a known defect covered under Subaru warranty extension bulletin 16-115-18. February 2023 — An authorized Subaru dealer documented the complaint in writing. The technician stated the vehicle never warmed up during the test drive and dismissed the concern. The CVT issue was never repaired. I was never informed of Subaru's CVT warranty extension program. February 17 2026 — seven days before my warranty expiration — the same authorized Subaru dealer physically identified and documented a CVT oil pump cover leak. The same jerking complaint was again documented in writing. No repairs were made and the warranty expired one week later. The CVT defect has been physically confirmed by an authorized Subaru dealer within the warranty period and Subaru of America has denied my warranty claim in writing. This issue presents a safety concern. The unpredictable jerking and hesitation when accelerating from a stop creates dangerous situations in traffic, particularly at intersections and when…”

“The contact owns a 2016 Subaru Outback. The contact stated that the passenger’s side wheel window trim was slightly pivoted. The vehicle was taken to the dealer who determined that the trim needed to be replaced. The vehicle was not repaired because the dealer had not confirmed if parts had been ordered or received. The contact stated that while driving approximately 60 MPH in 2020, the vehicle experienced transmission failure and the vehicle came to a jerking stop, as if the parking brake had been activated. The vehicle was towed to the dealer and the contact was informed that the CVT transmission had failed and needed to be replaced. The contact stated that approximately 4 years later, several warning lights illuminated. The vehicle was taken to the dealer but no cause for the failure was found. The contact stated that after leaving the dealer, the failure reoccurred. The vehicle was returned to the dealer and was diagnosed with CVT failure. The CVT transmission was replaced. The contact was informed that the wiring harness needed to be replaced; however, the wiring harness had not been replaced. The manufacturer was informed of the failure and opened a case.…”

“The "SELECT LEVER COMPLETE" or fear shift neutral park sensor switch stops working. Subaru has acknowledged the issue and issued a TSB (NUMBER: 16-112-18R). The issue is that the car does not sense it is in park or Neutral, even though the shifter is in that position. For keyed cars, the key cannot be removed and for push to start the car rear gate does not open and an alarm sounds when doors are open when the ignition is on. The car warns to move shifter to Park, even though the car is shifted to park. Car has been serviced several times with complaints indicating symptoms of issue, but was never informed of cause and lever select was never replaced.”

“Transmission went out at 72,000 miles. Was told it was not covered by warranty even though I purchased extended warranty. Will never buy another Subaru again. Spoke to a person at customer service who said she would take care of it. Made 19 calls over 3 months and no one returned a call. Terrible customer service at the main office.”

“The contact owns a 2016 Subaru Outback. The contact stated that the vehicle was taken to an independent mechanic to be serviced; however, while the mechanic was inspecting the vehicle, he noticed oil splatter inside the engine compartment. The vehicle was diagnosed with an oil leak. The contact stated that while driving at an undisclosed speed, the oil warning light illuminated. The contact related the failure to NHTSA Campaign Number: 15V502000 (Power Train). The manufacturer was not made aware of the failure. The failure mileage was 74,315.”