2022 Tesla Model 3 steering problems

“In a rented 2022 TESLA MODEL 3 entering a right veering on-ramp, the vehicle failed to respond to driver steering inputs at normal speed. I released the accelerator and there was no degenerative braking. I applied brakes, but the ABS was violently shaking without stopping and I noticed something illuminate on the computer screen. Unable to turn the steering wheel at all, we made severe impact with the left guardrail injuring both my wife([XXX]) and I. The Steering Assist Reduced warning light remained illuminated after the accident and I took a picture.”

“My Tesla was operating with Full Self-Driving (FSD) (Supervised) engaged when it initiated a left turn across the path of an oncoming vehicle traveling in the opposite direction, resulting in a collision. During the incident, FSD was controlling the vehicle's driving behavior and initiated the left turn despite the presence of oncoming traffic. The Tesla collided with the approaching vehicle while executing the turn. I am concerned that the FSD system failed to properly recognize or respond to oncoming traffic, failed to determine whether the left turn could be safely completed, or made an unsafe decision to turn across the path of another vehicle. This incident created a significant safety risk for the occupants of both vehicles. I believe the collision may indicate a safety-related problem involving FSD's intersection handling, left-turn decision-making, detection of approaching vehicles, or collision avoidance capabilities. I request that NHTSA review this incident as a potential FSD safety defect and obtain relevant FSD engagement records, vehicle telemetry, camera footage, steering commands, and collision data from Tesla to determine why the vehicle…”

“"Subject vehicle (2022 Tesla Model 3, VIN: [XXX]) was deployed for commercial rideshare passenger transportation by fleet operator Hertz/Uber with active catastrophic life-safety system failures. Onboard Tesla Service Mode telemetry confirmed: (1) Restraints Control Module (RCM) is powered OFF with status 00, leaving primary front and knee airbags and seatbelt pretensioners completely inoperative during public commercial transit; (2) Master Cylinder Hydraulic Brake Pressure telemetry is registered as 'Unavailable' under iBooster (IBST) and Electronic Stability Program (ESP); (3) Steering torque calibration offsets of -97 Nm and -14° angular pulling bias were applied to compensate for structural suspension collision damage; (4) Active diagnostic trouble code VCFRONT_a611 radiator heat rejection failure causing severe battery and powertrain thermal throttling; and (5) Non-functional windshield wipers and blocked camera sensors violating FMVSS 104 and FMVSS 208."”

“My 2022 Tesla Model 3 has experienced recurring intermittent loss/reduction of power steering assistance. The vehicle displays “Steering assist reduced – Steering may require increased effort.” The problem has occurred multiple times over a period of months and may disappear after the vehicle is power cycled or the alert clears. Tesla previously evaluated the vehicle for this condition. On July 8, 2026, Tesla documented the steering-assist-reduced complaint and recommended replacement of the RWD steering rack/steering gear, with an estimated repair cost of approximately $3,018. On August 20, 2026, the warning occurred again. Tesla Service Mode recorded fault EPAS3S_a005_sent2Mia, described as “Torque Sensor 2 signal not received,” with the potential impact listed as “Steering assist reduced.” The vehicle simultaneously generated UI_a020_SteeringReduced. The warning subsequently cleared again, but this is a recurring intermittent failure involving the vehicle’s electronic power-assisted steering system. I am concerned that the steering assistance could become reduced or unavailable while driving. Tesla has already determined that replacement of the steering rack…”

“I am the owner of a 2022 Tesla Model 3. The front control arms on this vehicle are defective as manufactured. From the factory, these components have demonstrated premature failure, abnormal noise, loosening, and/or separation risk that is not consistent with normal wear on a low-mileage vehicle of this age. Symptoms experienced include [describe your exact symptoms clearly and factually — examples: progressive clicking, clunking, popping, or creaking from the front suspension/wheel area; especially noticeable during low-speed turns, reverse, or over bumps; any feeling of looseness, pull, or change in handling; any actual detachment or near-detachment]. These symptoms began at approximately 75000 miles on July 27th 2026. This is not isolated wear. Front control-arm and related suspension-link failures (including lower lateral links that can detach from the subframe) have been the subject of multiple owner complaints, prior Tesla recalls (including NHTSA campaign 21V-835 for improperly torqued lateral-link fasteners on certain Model 3/Y vehicles and the later 23V-235 expansion), technical service bulletins addressing water intrusion and noise in upper control…”

“My car randomly gave me alerts that my steering alignment fault then came the following two days later Automatic Emergency Braking is unavailable Feature may be restored on next drive 20:55 | DI_a246 Automatic vehicle hold disabled Use brake pedal when stopping 20:55 | DI_a223 Traction control disabled Drive with caution 20:55 | APP_W264 Lane Departure Avoidance features unavailable Features may be restored on next drive 20:55 | DI_a222 Stability control disabled. I take my car to a mechanic and they show me that my lower control arms are damaged. Tesla is more than 2 weeks out for something that has caused my car to act completely unsafe and not normal.”