2017 Tesla Model S steering problems

“While merging onto the highway an error message showed up on the dash stating "Steering Assist May be Reduced" upon immediately after the steering froze and could only be moved slightly using significant force. Approx. 75lbs. I am athletic and work out and had trouble moving the car to the side. If my wife or daughter had driven the car they would not have been able to steer and this could have caused a significant accident, injury or death. Upon pulling over, I rebooted both computers on the Tesla Model S 75 D and the problem went away. I immediately drove to the Tesla dealer in Chesterfield, MO. There they seemed unconcerned, and advised me it was likely just a firmware issue and wouldn't be able to look at the car until the next week. I was shocked. Since the systems seemed to work I drove home and parked the car. On the driveway, the same error showed up and steering seemed again to lock up. After rebooting problem went away. Looking at the Tesla forums this seems to have happened before and poses a serious danger to the driver, occupants and fellow drivers on the road. I no longer feel safe driving the car.”

“The intermediate steering shaft is binding, causing difficulty turning the wheel and inconsistent steering wheel feel. It often will cause the full self driving to disengage during turns Tesla has revised the part that now includes a protective rubber bootyet has not issued a recall as the part accumulates debris and rust out and binding the universal joint”

“As I was driving down my driveway to the street the power steering failed. It was extremely difficult to then steer. My wife would have been unable to. I was able to re-enter the driveway, with GREAT difficulty from which the car was towed on a flatbed to the local Tesla service center. Had I been on busy city streets of highway I fear what would have happened. The service center cited the failure of a fuse ( fuse part # FUSE,BF180A,32V; #1071379-80-A) Though the car is a 2017 model the odometer shows 42,302 miles. I don’t know if this a systematic issue but I view it as a safety issue and so am reporting it.”

“Using software version 2025.14.1 with FSD (Full Self Driving) version 12.6.4. About 50% of the time the vehicle attempts and fails to change lanes when using FSD. It will: 1. Turn on signal and not change lanes, confusing cars around me. Or more often 2. Swerve between lanes indefinitely. See example at [XXX] It drives like a drunk driver.”

“The contact owns a 2017 Tesla Model S. The contact stated that prior to the failure experienced, there was an abnormal clicking sound coming from the steering wheel. The contact attempted to start the vehicle, and upon starting the vehicle, the message "Service Power Steering" was displayed, and the EPS warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.”

“The car was on park for charging. When charging was at 75%, when it was complete, the car was put on drive. Auto-steering disengaged message came up. The steering was stuck and could not be turned. After multiple tries, called Tesla road side assistance which resulted in car getting towed to service station. The steering rack had to be removed and replaced. I cannot imagine if this happened when the car was on a higher speed road.”