2003 Toyota Corolla power train problems

“HI, I AM FROM PUERTO RICO. I HAVE A TOYOTA COROLLA 2003 1.8L, TYPE S. THE TRANSMISSION OF MY CAR IS MANUAL AND IT IS MAKING AN INTERNAL NOISE THAT HAS BEEN INCREASING LITTLE BY LITTLE. THE NOISE IS SIMILAR TO A BALL BEARING WHEN DAMAGED. FOR THE CURRENT PRICE IN THE MARKET, THE MECHANIC RECOMMENDED ME TO CHANGE THE TRANSMISSION FOR ANOTHER USED ONE THAT IS IN GOOD CONDITION. I HAVE ALWAYS MAINTAINED MY CAR AND I AM SURPRISED THAT A MANUAL TRANSMISSION CAR IS FAILING. THIS MODEL HAS PRESENT PROBLEMS IN THE TRASMITION? THANKS, LISA HERNANDEZ”

“REAR WHEEL BEARINGS FAILURE (SAFETY DEFECT) -- 2003 TOYOTA COROLLA. EXCERPTS FROM MY E-MAIL TO TOYOTA MOTOR SALES, U.S.A. INC. FOLLOW: "THE LOCAL TOYOTA DEALERSHIP HAS RECENTLY RECOMMENDED REPLACING THE REAR HUB AXLE BEARINGS DUE TO A HUMMING NOISE, AT A COST OF OVER $1,000.00. THIS RECOMMENDATION HAS FLOORED ME AS THIS TYPE OF REPAIR FOR A VEHICLE WITH ONLY 90,000 MILES DOES NOT SEEM TO BE CONSISTENT WITH THE QUALITY STANDARDS PROMULGATED BY TOYOTA MOTOR CORPORATION. APPARENTLY, THIS PROBLEM IS WIDESPREAD AS A TECHNICAL SERVICE BULLETIN (NHTSA #10015608) WAS ISSUED." THE TOYOTA CUSTOMER EXPERIENCE CENTER SUBSEQUENTLY ACKNOWLEDGED THE REAR WHEEL BEARINGS ISSUE ADDRESSED IN MY E-MAIL ABOVE, CREATING CASE # 1703301220. DESPITE TOYOTA HAVING ISSUED TECHNICAL SERVICE BULLETIN #00105 ON THIS VERY MATTER, THE TOYOTA REPRESENTATIVE AT THE CUSTOMER CENTER CLEARLY STATED IN A SUBSEQUENT PHONE CALL THERE IS NO WARRANTY COVERAGE, NO CUSTOMER NOTIFICATION, AND NO-RECALL ISSUED. AFTER CONTACTING THE TOYOTA CUSTOMER EXPERIENCE CENTER, I WAS RELUCTANT TO REPLACE THE REAR WHEEL BEARINGS FOR ALMOST $1,000.00 IF THE ONLY ISSUE WAS WITH HUMMING WHICH BLENDED IN WITH NORMAL ROAD…”

“ORIGINAL TRANSMISSION WAS REPLACED AT 124,000 MILES, AND ONLY 3 YEARS LATER, AND 25,000 MILES LATER, IT NOW NEEDS ANOTHER TRANSMISSION. NOT THE DEPENDABILITY I WAS EXPECTING. IN BOTH INSTANCES, THE SAME THING OCCURRED; ALTHOUGH IT WENT OUT ON ME A LOT FASTER THE SECOND TIME AROUND. I HEARD A GRINDING SOUND EVERY TIME I ACCELERATED, UNTIL IT FINALLY WENT OUT ON ME AND LOCKED UP BOTH TIMES. THE FIRST TIME I WAS ON A SIDE STREET, AND IT HAPPENED WHILE I WAS APPROACHING RED LIGHT (AND ONLY REVERSE WORKED, SO I WAS ABLE TO REVERSE IT INTO A GAS STATION NEARBY). THE SECOND TIME WAS A BIT MORE SCARY (AND I'M PISSED OFF ABOUT THIS EVEN MORE, NOW THAT I'M READING EVERYONE ELSE'S STORY, BECAUSE I COULD'VE BEEN IN A MAJOR ACCIDENT). I WAS DRIVING 65 MPH DOWN THE FREEWAY (IN THE 3RD LANE IN) WHEN ALL OF A SUDDEN MY CAR BUCKED (JERKED BACK) ON ME. I IMMEDIATELY GOT OFF THE FREEWAY WITHIN 5-7 SECONDS (THANK GOD I WAS ABLE TO), WHEN ALL OF A SUDDEN IT COMPLETELY FROZE/SEIZED/LOCKED UP ON ME AND PROCEEDED TO SKID OUT ABOUT 15 FEET ALONG THE SIDE OF THE FREEWAY ONLY A SECOND OR TWO AFTER GETTING OFF. THE MORE I THINK ABOUT IT, THE MORE I AM THANKFUL THAT I WAS ABLE TO GET OVER…”

“IN 9/2007 THE TRANSMISSION AND CLUTCH WENT OUT ON MY MANUAL 2003 COROLLA. CONVENIENTLY, IT WAS BEYOND THE WARRANTY PERIOD. I SPENT A SIGNIFICANT AMOUNT OF $ REPAIRING. AGAIN, IN MARCH 2015 THE TRANSMISSION AND CLUTCH ARE GOING OUT ON MY MANUAL VEHICLE. AFTER RESEARCHING, I FOUND NUMEROUS OWNERS EXPERIENCING THE SAME PROBLEMS. THERE IS A SERIOUS DEFECT IN THE 2003 MANUAL COROLLA THAT WAS APPARENTLY FIXED IN THE 2004 VERSION. I HAVE CONTACTED TOYOTA SEVERAL TIMES. THEY WILL DO NOTHING. THEY TOLD ME TO EMAIL THE NHTSA AND YOUR AGENCY WOULD DETERMINE A RECALL. PLEASE, PLEASE, PLEASE PUT THIS PROBLEM ON THE RECALL LIST. I (AND NUMEROUS OTHER OWNERS) HAVE BEEN STRANDED ALONG THE HIGHWAY AND IT IS NOT SAFE! *TR”

“I WAS STOPPED AT A RED LIGHT. WHEN IT TURNED GREEN I STARTED TO ACCELERATE AND TURN THE TRANSMISSION BLEW. SUBSEQUENTLY, I WAS READ ENDED. I STARTED TO DO RESEARCH AND FOUND THAT THE 2003 TOYOTA COROLLA HAS EXCESSIVE TRANSMISSION ISSUES. *TR”

“I WAS DRIVING DOWN FREEWAY AT 55MPH AND WITHOUT ANY WARNING TRANSMISSION MADE LOUD NOISE AND THEN LOCKED UP, SINCE CAR IS FRONT WHEEL DRIVE I HAD NO STEERING AS FRONT WHEELS LOCKED UP. CAR THEN STARTED TO GO INTO A SPIN, BUT I WAS ABLE TO FIGHT THE WHEEL AND STEER CAR TO SIDE OF ROAD. IT WAS ONLY BY LUCK THAT THERE WERE NO OTHER CARS OR TRACTOR TRAILERS ALONG SIDE OR IN BACK OF ME, AFTER ALL SAID AND DONE WITH TOWING COST AND HAVING TO RENT A CAR FOR WORK, I AM OUT $645.00 AND STILL NO CAR! I HAD TWO TRANSMISSION REPAIR SHOPS LOOK AT CAR, BOTH SAID THE SAME THING THAT SOME PART CAME LOOSE IN TRANSMISSION AND DESTROYED IT, IT WOULD NEED TO BE COMPLETELY REPLACE AT A COST OF $2700 -$3300 IN THE MEANTIME I STARTED DOING RESEARCH ON THAT TRANSMISSION AND WHAT I WAS TOLD BY THE REPAIR SHOPS AND FROM MY OWN RESEARCH IT IS VERY CLEAR THAT THE #TOYOTA COROLLA AND OTHER MODELS THAT USED THAT MANUAL TRANSMISSION HAVE HAD THE VERY SAME PROBLEMS. PLEASE DEMAND A RECALL !!! *TR”