2005 Toyota Corolla fuel system, gasoline problems

“TL* THE CONTACT OWNS A 2005 TOYOTA COROLLA. WHILE STOPPED AT A RED LIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 46,000. UPDATED 02/03/17*LJ”

“IN JANUARY OF 2013 AND AGAIN IN DECEMBER OF 2013, MY "CHECK ENGINE" LIGHT CAME ON. I TOOK THE CAR INTO THE TOYOTA DEALERSHIP IN SAN LUIS OBISPO AND THEY SAID THAT THE O2 SENSOR WAS MALFUNCTIONING, CAUSING THE ENGINE TO RUN TOO LEAN. THE FIRST TIME THIS HAPPENED (JANUARY, 2013) THE SERVICE WRITER GAVE ME AN ESTIMATE TO REPLACE THE "PLENUM GASKET AND O2 SENSOR" BUT SAID THERE WAS NOTHING TO WORRY ABOUT IF I ELECTED NOT TO HAVE THIS REPAIR DONE. WHEN THE "CHECK ENGINE" LIGHT CAME ON AGAIN IN DECEMBER, 2013, I BECAME ALARMED AND TOOK MY 2005 TOYOTA COROLLA TO AN AUTHORIZED TOYOTA REPAIR SHOP (NOT THE SAN LUIS OBISPO DEALERSHIP) AND WAS TOLD THAT THERE WAS HIGH PROBABILITY THAT THE VALVES WOULD BURN OUT IF I DID NOT REPLACE THE O2 SENSOR (BANK ONE, SENSOR ONE) AND PLENUM GASKET. I FELT THIS WAS URGENT AND TOOK IT TO THE SAN LUIS OBISPO TOYOTA DEALER FOR THE REPAIR, COSTING ME OVER $400. NOTE THAT I FOUND A TOYOTA TECHNICAL SERVICE BULLETIN ("M.I.L "ON" DTC PO171 OR P2195", MODELS '05-'06 COROLLA AND MATRIX) DATED NOVEMBER 16, 2005 (WE BOUGHT THE CAR IN MARCH OR APRIL, 2005) WHICH STATED "UNDER CERTAIN DRIVING CONDITIONS, SOME 2005 AND 2006 MODEL YEAR COROLLA AND…”

“CHECK ENGINE LIGHT CAME ON. DROVE FOR APPROXIMATELY 20 MINUTES MORE WHEN ENGINE COMPLETELY SHUT OFF CAUSING CAR TO RAPIDLY DECELERATE AND NEAR-MISS REAR-ENDING. *TR”

“TRAVELING SOUTH ON I-95, SPEED 71 MPH, ENGINE STOPS. I CAREFULLY AND PROMPTLY PULL OVER TO RIGHT SHOULDER, CALL AAA AND HAVE VEHICLE TOWED TO LOCAL FIRESTONE REPAIR FACILITY. AFTER PERFORMING DIAGNOSTIC FIRESTONE INFORMS ME THE FUEL PUMP HAS FAILED AND REPLACES THE FUEL PUMP. I REQUEST AND RECEIVE THE ORIGINAL FUEL PUMP. PREVIOUSLY I HAVE OWNED 3 COROLLAS AND HAVE DRIVEN EACH OF THEM OVER 150,000 MILES WITH NO FUEL PUMP FAILURES. I AM REPORTING THIS INCIDENT BECAUSE I FEEL THAT THIS FUEL PUMP MIGHT HAVE BEEN FAULTY AND COULD BE VERY DANGEROUS UNDER CERTAIN CIRCUMSTANCES. *TR”

“2005 TOYOTA COROLLA. CONSUMER WRITES IN REGARDS TO A POSSIBLE FUEL PRESSURE REGULATOR *TGW THE CONSUMER STATED GAS WAS LEAKING ONTO THE ENGINE. THE FUEL PRESSURE REGULATOR AND RAIL HAD TO BE REPLACED.*JB”

“IN APRIL,2011 TOOK CAR WITH 32120 MILES INTO DEALER FOR TOYOTA ENGINE COMPUTER RECALL REPLACEMENT.. SHORTLY AFTER REPLACEMENT APP. 50 MILES THE CHECK ENGINE LIGHT CAME ON. I RETURNED TO DEALER ON 5/23/2011 MILEAGE AT THIS TIME WAS NOW 32599 AND WAS TOLD THAT IT WOULD COST APP. $77 TO FIX THE PROBLEM WHICH WAS THE GAS CAP WHICH WAS LEAKING FUMES. I DID NOT HAVE THE WORK DONE BUT I DID HAVE THE GAS CAP CHECKED AT A CERTIFIED SMOG STATION AND CAP WAS FOUND TO BE OK. I WAS NOT SATISFIED WITH THE ANSWERS I WAS RECEIVING SO I CALLED TOYOTA CORP. CUSTOMER SERVICE AND EXPLAINED THE PROBLEM. I WAS TOLD THAT THEY WOULD CONTACT THE DEALER AND HAVE THEM CALL ME TO FIX THIS PROBLEM. LATER THAT DAY THE SERVICE MANAGER CALLED AND REQUESTED THAT I BRING THE CAR IN THAT DAY AND HE WOULD HAVE IT DIAGNOSED FOR FREE TO SEE WHAT THE PROBLEM WAS. I TOOK THE CAR IN AND AFTER A PERIOD OF TIME THE SERVICE TECH. SAID THEY FOUND THE PROBLEM MY FUEL FILLER NECK AND GAS CAP NEEDED TO BE REPLACED DUE TO RUST AND CORROSION AT A COST OF OVER $400. I ASKED IF THIS WAS COVERED BY TOYOTA BECAUSE THE CAR ONLY HAS 33763 MILES AND WAS TOLD NO, I LIVE IN A DRY DESERT AREA SO I DON'T SEE WHY I'M…”