2019 Toyota Highlander fuel/propulsion system problems

“My husband was driving my car out of town, and while driving approximately 70 mph, my car stopped going. When he pressed the gas pedal, the engine revved, but did not move forward. He had to coast down the interstate and pull over on the side of the road. He said he almost got tear ended by a semi-truck. I called roadside assistance through my insurance company and it took them 2.5 hours to get to us. We had to have it towed about 70 miles to a shop and pay $184.00. The body shop we towed it to said it is the transmission. He said he knew it to be a common issue with 2019 Toyota Highlanders. I looked it up online and found several instances of similar stories. There was no warning.”

“My car is stalling and stopping while driving both slow speeds and high speeds and all displays are going off, it may restart after several attempts, it seems a serious safety problems, however my VIN is not part of original Toyota Fuel pump recall, however it seems my issue is also related to Fuel pump mall functions”

“Vehicle engine is running rough and threatened to stall in traffic due to a failed low-pressure fuel pump. This model year is under a major fuel pump recall, but my VIN was excluded. The gauge isn't reading correctly either”

“I am filing this safety complaint regarding a known defect in my 2019 Toyota Highlander Hybrid related to the high-pressure fuel system. My vehicle triggered a Check Engine Light with Diagnostic Trouble Code P107B - Fuel Rail Pressure Sensor ‘B’ Circuit Range/Performance. This code appeared multiple times (3 stored faults). Toyota has formally acknowledged this defect by issuing Technical Service Bulletin T-SB-0050-20 specifically for 2018-2019 Highlander Hybrid vehicles. This is a fuel system pressure issue that directly affects the safe and reliable operation of the vehicle. A failure in the fuel rail pressure system can cause: •Sudden loss of engine power while driving •Unexpected stalling at highway speeds •Inability to accelerate when needed, creating a dangerous situation in traffic Despite Toyota acknowledging this defect through TSB T-SB-0050-20, Jim Coleman Toyota (10400 Auto Park Ave, Bethesda, MD 20817, Phone: 301-618-0480) quoted me nearly $3,000 to repair this issue rather than covering it under warranty. I believe Toyota should issue a formal recall to protect all owners of affected vehicles. I am requesting that NHTSA investigate this matter and…”

“Vehicle has experienced sudden stalling while driving and an intermittent Check Engine Light with Diagnostic Trouble Code (DTC) P107B — Fuel Rail Pressure Sensor “B” Circuit Range/Performance. This is the exact condition covered by Toyota Technical Service Bulletins T-SB-0050-20 and T-SB-009-23, and Customer Support Program 23TE04 (Denso low-pressure fuel pump settlement coverage, valid until July 15, 2036 or 150,000 miles). Timeline: • Late April 2026 (while driving ~300–400 miles from home): Vehicle stalled without warning at a red light. • May 5, 2026 (while driving on freeway ~50–75 miles from home): Check Engine Light illuminated. AutoZone scan and dealer diagnostic tool both confirmed DTC P107B. • May 5, 2026: Dealer performed health check using Toyota GTS+ tool (see attached screenshot taken at 15:58:01). Screen clearly shows “PERMANENT: YES” confirming a permanent stored fault code. • May 5–15, 2026: Crown Toyota (Ontario, CA) confirmed the code was present on arrival (Repair Order 2842115 dated 05/15/26). They later cleared the code, performed a short test drive, could not duplicate the fault at that moment, and closed the repair order as…”

“Check engine light came on without warning, car started losing power, idling roughly, stalling out, and not wanting to start. Had my battery, alternator, and starter checked and they are all fine. Diagnostic test showed it was to do with how much fuel/air the vehicle is getting. The check engine light goes off and on as I’m still having to try and drive my vehicle to and from work due to not having other transportation.”