39 owner complaints to NHTSA about the 2005 Toyota Prius cite steering, 4% of all 1,051 complaints for this model year. NHTSA also lists 2 recalls on this component.
“I had lost functionality for some buttons on the steering wheel that didn't directly impact safety. On replacing the clockspring mechanism inside the whweel I decided to inspect the old unit. Four of the lines in the flex cable are impacted by corrosion, three have already failed. The fourth line is one of the airbag's electrical lines. I'm filing an issue report because the airbag would be next impacted by this failure and I believe there's a fair chance the corroded line could fail during the vehicle's attempt to fire the airbag on the wheel.”
“THE STEERING ON MY 2005 PRIUS WITH ROUGHLY 119,000 MILES FAILED. FORTUNATELY IT WAS AT A LOW SPEED AND ON A SIDE STREET BUT WITHOUT ANY ABILITY TO STEER THE CAR, IT COULD HAVE BEEN REALLY BAD IF ON A MAIN ROAD OR AT A HIGHER SPEED! THE CAR IS CURRENTLY WITH A TOYOTA DEALER AND THE CAUSE IS YET TO BE DETERMINED. TOYOTA STATED THERE IS NO RECALL OUTSTANDING ON THE CAR AND IT WOULD BE OUT OF POCKET. THERE WAS, HOWEVER, A PRIOR RECALL FOR STEERING ISSUES. WHEN IT FAILED, I WAS ABLE TO MOVE IT BACK AND FORTH BUT THE WHEELS WOULD NOT TURN AT ALL.*DT*JB”
“THIS IS AN ONGOING PROBLEM WITH THEIR INTERMEDIATE SHAFT. THEY HAVE NEVER COMPLETELY RESOLVED THE RECALL ISSUE, AS IT CONTINUES TO THIS DAY.*DT CONSUMER CONTACTED THE MANUFACTURE, SINCE RECALL WAS ALREADY REPLACED ONCE CONSUMER WAS TOLD THEY WOULD NOT BE RESPONSIBLE. ALSO, CONSUMER WENT TO THE DEALER TO GET A RECALL HISTORY, SHOWS THAT SHAFT HAS BEEN REPLACED TWICE.*JB”
“STEERING IS STICKY ON TURNING WHILE DRIVING. KIND OF JERKY. TOYOTA DEALER IN FT. MYERS, FL. SAID THEY DID ALL RECALLS. I DON'T THINK THEY DID. IS THERE PROOF OF RECALLS ON MY CAR? THANKS, [XXX]*DT *TR*JB”
“TL* THE CONTACT OWNS A 2005 TOYOTA PRIUS. WHILE DRIVING AT ANY SPEED, THE STEERING WHEEL FELT LOOSE AND THE VEHICLE WAS UNSTABLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS NOT A RECALL ISSUE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND RESTATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 193,000. *DT*JB”
“TAKATA RECALL, DASH (SOUNDS LIKE SOMETHING IS LOSSE) WHEN DRIVING OVER BUMP OR AT HIGHER SPEEDS. THEN I TOKE IT TO THE DEALER THEY SAID THAT'S STEERING COLUMN PROBLEM.”
Showing 6 of 39 reports. Read every report on NHTSA.gov.
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.