2006 Toyota Prius service brakes problems

“I was involved in an auto accident on 4/20/2026 @ 6:23 PM. I was driving a 2006 Prius and the vehicle in front of me stopped to make a left turn. I applied my brakes, which grabbed slightly and then released. I then had to hit the brakes hard and they did the same thing again. I ended up rear-ending the vehicle in front of me and had to go to the hospital. I’ve been out of work since the accident, and I feel this was not my fault DUE TO FAULTY BRAKING SYSTEM ON THIS VEHICLE. My vehicle was declared a total loss, by the insurance company After doing my own research I have found many accidents with this type of vehicle that has had rear end accidents with injuries and some fatalities. it also shows not only this 2nd generation with this problem however the 3rd generation Prius as well. I have been out of work since the accident. I'm asking for a complete and thorough investigation into this and a satisfactory resolution to this so that it doesn't happen to anyone else. There were no warning indicators of any kind prior to the accident plus I had paid over 2000 dollars' worth of work and a set of 4 new tires put on this vehicle prior to this incident. Please advise and thank you.”

“I am looking to receive a little bit more assistance regarding my daughter's first car that she worked very hard for. It is a 2006 Toyota Prius. It was garage-kept and owned by an older couple who only put 85,000 miles on it. It is really a gem of a car. Soon after we registered the car, my daughter was out driving with her father. While going through a 4-way stop, she found that the brakes had failed and she was unable to stop at the intersection. Luckily, she was with her father, and he was able to give her verbal instruction to guide the both of them to safety. Upon further investigation, we learned that there was a recall on the Brake Actuator Assembly in 2016. Which is the part that has failed and almost caused my 16 year old daughter to crash the car she worked hard for. I contacted the Toyota Brand Engagement Center. It was stated to me that the recall has expired, however, I feel that the fact that a recall was issued means that it was recognized by Toyota that the vehicle was sold with a faulty brake system. This, in and of itself, is a hazard and could be fatal. This should be addressed and the brake system should be replaced as it is no fault to any…”

“The following describes a near total failure of the brake system that accompanies and is triggered by routine aging of the battery. I believe this applies to multiple model years and editions of the Prius, based on reports by other owners on owners' discussion groups. I believe this should have the highest severity level. Here is what happens: An alarm is sounded, several warning lights ABS, VCS appear, and soon after that, the front brakes stop working. The rear brakes then prove ineffective and lock up. The happens with high frequency under any of the following conditions: (a) as the battery approaches 3yrs age, (b) it is excessively cold outside. (c) there is a higher than typical load on the 12V system from any of a variety of reasons. After installing a fresh new 12V battery, the above happens with much less frequency. There no warning on the dashboard to indicate that the condition of the 12V battery is not safe for operation of the vehicle. It seems clear that the route cause is that the brake control unit is configured within inadequate tolerance for the normal aging of the 12V battery, compounded by the absence of warning on the dash. This probably…”

“The actuator failed. The car is no longer safe to drive. This is a known issue. The company refused to fix the issue or recall the car. The warning lights and a loud beep are present if the vehicle is started.”

“Brake actuator is not working properly and will eventually get us in an accident. We bought the car brand new. There is a recall for this issue, but we were never notified by Toyota. After contacting Toyota, they claim we are out of the recall dates and will do nothing. I have requested a copy of the letter they should have sent you notifying us of this issue. They cannot provide one. I would like to be able to fix this car; I cannot afford another car or such an expensive repair caused by a defective Toyota part. Please, help us. Thank you.”

“Power braking goes out and ringing in car with brakes and abs light on. Have to press extra hard to brake car. Also anther time coming out of a parking lot in reverse and brakes just stopped car as if I had hit something but had not hit anything.”