2010 Toyota Prius electrical system problems

“The contact owns a 2010 Toyota Prius. The contact stated that while driving at an undisclosed speed, a strong and unusual odor was detected inside the vehicle with no warning lights illuminated. The contact further stated that the following day, upon entering the vehicle, both the contact and the contact’s spouse experienced headaches, nausea, and cognitive discomfort. Concerned about possible exposure to harmful fumes, the contact inspected the vehicle and determined that the vehicle’s battery appeared to be inoperable. The vehicle was taken to a dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The contact expressed concern that the failure presents a serious safety hazard due to potential exposure to toxic fumes within the cabin. The contact noted that the situation could have been more severe if a child had been present in the vehicle at the time of the incident. The failure mileage was approximately 75,000.”

“i have have 2 problems, both was recalls, but this one they say expired in 2021 when i bought the car and toyota dealer didnt tell me had recall so i could fix it before it expired. there is a class action lawsuit in the brake booster, master cyclinder actuator abs pump fialing loosing brakes making grrr noises leaking all brake fluid out continously dangerous to drive can cause bad accident wreck since i drive down the hwy alot and this is the only car i have to drive, i also have dc inverter module /sensor that is killing off 3 batteries now that i installed in 3 months, and toyota dealers wont fix unless it shows error but its a recall so since problen should fix this recall but wont pay for it to fix it even though it a recall right now that is not expired. im upset 3 dealers wont do it unless then charge me to do it. when toyotal mfg take it to any dealer and they will fix free but no one will do it. toyota mfg needs to make these dealers fix these 2 recalls on this car that can kill me and my passengers and anyone on the road that i could hit by not haivng controll brakes or the hybrid system shuttong completely down and could even kill a pedestrian with…”

“brake booster that was a recall that toyota said expired in 2020 when i bought the vehicle and the toyotal dealer didnt inform me of the recall to fix it said everything was fine when it was not, i had a dc inverter sensor brake booster issues and now it ills off my 12volt battery every time i put one in lasts about 1 mth, upset dealer never told me this wjhen took in tel me any recalls or probelms, they said none, they lied to me. it kills off my 12volg agm batteries in the last 7 mths been having braking booster issues problems grrr,,, noise all the time when the car is off too, its killing off my hybrid system and my temathetics module is having issues too because of all this and evey battery i put in the car, i want the ntc gov to have toytota recall fix these problems with my car and not expire the recall they had in 2020 cause now i cant fix my car cause of it, i was lied to by the lavista toyota dealer that it has no probblems in 2020 of august when i bought it no recalls and this recall could have been fixed if they would have been honest. unexpire the recall on my brake booster and my dc inverter and sensors probelms killing off my new batteries all…”

“It is a known problem that Priuses manufactured from 2004 to 2015 have issues with the brake master cylinder and brake booster accumulator. When the vehicle computer recognizes an internal leak (ABS C1391) or other issue in the accumulator pump, it completely disables the regenerative braking system, which significantly reduces braking power. In my case, the problem is intermittent, and the vehicle computer will occasionally clear the code and operate normally. A slight whirring sound can still be heard (indicative of an internal leak), leading me to conclude that the part is still damaged, even when the code clears itself. This continues to affect my and my passengers' safety because the problem comes back with no warning while driving. Many times at highway speeds, the regenerative braking system will shut off while decelerating. This has caused scares and near-accidents. Imagine you are approaching stopped traffic while traveling 65 miles per hour. You press the brake to start slowing down, and while decelerating, the dashboard lights up and the brake pedal goes spongey. Now, you must slam the brake all the way into the firewall to engage the disks and pads…”

“Toyota issued a recall with a limited time for Prius brake booster/actuator failures. This issue is known to present brake failures and necessarily place drivers, passengers, and pedestrians at risk in the case of such brake failures. Toyota made no effort to proactively remedy this problem and further neglected customer safety by excluding Priuses with the same manufacturing issue from the recall, under its 10 year 150,000 mile requirement. Whether or not the Priuses have been driven 150,000 miles or 10 years the nature with which the malfunction presents represents a safety for any driver.”

“The ABS Pump( Accumulator and booster) are regularly failing on all Toyota Prius( 2010-2015). When the ABS pump starts to fail, the warning lights for Traction control, Brake and ABS come on. These lights come on at all speeds and its very hard to bring the vehicle to a complete stop when this happens. The brakes completely stop working and the brakes become rock solid. The brakes become so hard that they can’t be possibly be depressed to stop in time. I nearly missed getting killed from this as I am out of country and Toyota is refusing to fix it since its not a recall and I am in Canada. Toyota is asking $3500 in parts and $1500 in labor to repair. I can not afford it and this issue is on all Prius from 2010-2015. This is a major safety hazard and can cause serious injury and damage. Toyota is refusing to repair it since they believe the cars are out of warranty. However Toyota has been notified about this safety hazard arising on all Prius(2010-2015) but decline to respond or take action. I urge NHTSA to take action and get this resolved as the ABS brakes failing on the Prius can be really dangerous and can cause life threatening accidents.”