2016 Toyota Prius electrical system problems

“Car was driving fine one day and then while driving down the interstate I had the Pre collision system malfunction error, Brake light came on, Cruise will not operate, ABS light is on. After much research it seems Prius V has a common issue with brake booster faulting.”

“During summer months when temperatures are above 100 degrees when accelerating from a complete stop I can hear the engine rev and the RPMs increase but the vehicle will move at 1-2 mph. Even if the accelerator is to the floor. After 3-4 seconds the tires will squeal and the vehicle will be jolted forward then it will slowly accelerate. This happens occasionally and I have taken it to a Toyota dealership and a chain mechanic shop, neither have been able to recreate the problem. There are no warnings and no error codes. I have been stuck in the middle of intersections trying to turn left, I have not been hit, but I fear it will happen. There is a recall out for this issue on other Priuses and I believe the issue needs to be investigated further as there is another complaint on this site for the same issue and I have found it on other sites. I bought the car in fall of 2019 and this problem has been occurring since summer of 2020.”

“While driving vehicle on the freeway it stated braking power low, stop in a safe place, antilock brake system malfunction, pre-collision system malfunction, lane departure alert malfunction. I was almost in a major scary accident.”

“The contact owns a 2016 Toyota Prius. The contact stated while driving at approximately 70 MPH, the steering wheel stopped operating and the vehicle began to shut down. The contact stated that a yellow blinking light and a hybrid system malfunction warning light illuminated the instrument panel. The vehicle was taken to an independent mechanic where it was diagnosed that the hybrid battery was low and there was a failure of the engine wiring harness. The hybrid battery was able to recharge but the dealer stated that the electric wiring harness needed to be replaced. The vehicle was not repaired. A dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was approximately 159,141.”

“When the battery cooling fan is running, the car is slow to accelerate or will not accelerate at all. The incident has happened multiple times over the past year when the temperatures are above 90. If at a complete stop, the car will not accelerate, it will only jerk forward. The car has to be turned off and restarted to be able to accelerate. If braking or reducing speed, the car will be sluggish, and I have not been able to get the speed over 40 mph. I have taken it to the dealership, but they said they could not recreate the issue, though I do not believe that they followed the directions I gave them to recreate the problem. No warning lights appear when the issue occurs, so they did not have an answer. The first time the incident occurred, I had just had the scheduled maintenance completed two days earlier and they did not find anything in the inspection that needed to be repaired. The first time the incident occurred, I was at a stop light trying to make a right turn. The incident has occurred twice when trying to pull on to the highway and accelerate up to speed.”

“Vehicle stalls for 5-10 seconds when stopped at a red light. Seems to happen sporadically and is difficult to reproduce. There have been other reports of it online here: https://priuschat.com/threads/tsb-nimh-only-reduced-power-when-accelerating-from-a-stop.187455/ https://priuschat.com/threads/2017-prius-2-no-acceleration-movement-from-full-stop.209317/ https://priuschat.com/threads/2016-prius-2-stalling.200606/”