2007 Toyota RAV4 suspension problems

“The contact owns a 2007 Toyota Rav4. The contact stated that the vehicle could not be aligned. There were no warning lights illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 16V596000 (Suspension). The vehicle was taken to a tire shop, and the contact was informed that the rear tie rods were welded, and an alignment was impossible. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 182,342.”

“The contact owns a 2007 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormally loud sound coming from underneath the vehicle. The vehicle was taken to an independent mechanic, where the contact was informed that the sound was coming from the tires. The contact was informed that no issues were found. Additionally, the contact stated that the check engine warning light, the traction control warning light, and an unknown warning light were illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown. The VIN was not available.”

“Subframe rusted in half, the only way I found it was when we put new shocks on it. It peeled off about 1/2 the tread on a brand new tire. Dangerous, if passengers side rear tire would've broke loose it would throw rear of car into oncoming traffic!”

“The contact owns a 2007 Toyota Rav4. The contact stated while installing new tires on the vehicle, the mechanic stated that the wheel bearings fractured and that both front axles were rusted. The vehicle was taken to several independent mechanics, and it was confirmed that the wheel bearings were fractured and that the front axles were rusted. The vehicle was not repaired. The dealer was contacted, and the contact left a message. The manufacturer was not contacted. The failure mileage was 179,000.”

“WHILE DRIVING STRAIGHT DOWN THE HIGHWAY THE THERE WAS A POP SOUND IN THE BACK OF THE VEHICLE AND I WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE. THIS LEAD TO THE RAV4 COMING TO A STOP AFTER IMPALING ON GUARDRAIL FROM FREEWAY SPEEDS. UPON INSPECTION IT APPEARED THAT THE REAR LEFT WHEEL WAS THE CAUSE AND WAS AT AN ANGLE INSTEAD OF BEING PERPENDICULAR TO THE GROUND LIKE THE REST OF THE WHEELS.”

“TL* THE CONTACT OWNS A TOYOTA RAV4. THE CONTACT STATED WHILE DRIVING AT 30 MPH, THE VEHICLE EXPERIENCED A WOBBLE IN THE FRONT SUSPENSION. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO BOB TYLER TOYOTA LOCATED AT (7201 PENSACOLA BLVD, PENSACOLA, FL 32505) WHERE AN UNKNOWN RECALL REPAIR WAS PERFORMED. THE CONTACT STATED THAT THE REAR TOWING ROD BAR WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE REAR TOW ROD BARS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000. *BF*JB”