2014 Toyota RAV4 power train problems

“UPDATE TO PRIOR COMPLAINT — Filed April 2, 2026. VIN: [XXX] . 2014 Toyota RAV4 AWD XLE. Team Toyota Langhorne, 746 E Lincoln Hwy, Langhorne PA 19047. Vehicle remains out of service — 53 days as of April 10, 2026. SECOND REPLACEMENT VEHICLE — April 4-5, 2026: Dealership presented 2014 RAV4 VIN [XXX] as replacement. Upon visual inspection: valve cover leaking; blue silicone sealant on valve cover applied unevenly indicating prior engine disassembly or concealed active oil leak; catalytic converter flanges rotted top to rear requiring full replacement; oil on bottom of motor. Photographs available. Dealership declined to repair at estimated cost of $2,500 — April 6, 2026. DEALER RESOLUTION FAILED — April 7, 2026: Bill Sullivan, Pre-Owned Sales Director, offered buyback or trade. Both rejected as inadequate. No resolution provided. Two defective replacement vehicles presented — neither acceptable. Cases: [XXX] / [XXX] / [XXX] [XXX] — [XXX] — [XXX]”

“2014 Toyota RAV4 AWD XLE purchased June 2025. Multiple pre-existing safety defects confirmed by dealership personnel were never disclosed at time of sale. POWER TRAIN: Torque converter failure — vibration documented at pre-sale inspection, never disclosed or diagnosed. Axle bracket corroded so severely it was fused to axle and required cutting off — confirmed by service advisor on recorded call. BRAKES: Aftermarket brake parts installed pre-sale without disclosure. Brake system rated RED by dealership within 9,734 miles of purchase. Severe brake pedal pulsation confirmed on multiple invoices. ODY/STRUCTURE: Severe underbody and structural corrosion — subframe, crossmembers, fuel tank surfaces — never disclosed. Swollen lug nuts documented. Prior welded exhaust repair undisclosed. Exhaust flange separation and catalytic converter failure — repair quote 4,745. SEAT BELT: Rock found lodged in seat belt buckle — safety restraint failure — not noted on pre-sale inspection. RECALL 23V734000 / 23TA13: Aftermarket battery used as recall remedy — OEM replacement required — non-compliant — fire risk not disclosed at sale. All defects confirmed by dealership invoices, MPI…”

“Transmission fluid was serviced at Bill page Toyota, Falls Church, VA 22042 (102,468 miles on 11/2/2023) Transmission failed to operate at 104,771 miles. Car failed to go reverse, noise from transmission gear. Car was inspected at Toyota Ourishman, Fairfax, VA and concluded transmission problem failed.”

“This matter is not related to a accident. This matter is related to a bad transmission on our Rava4. This started at a little over 100.000 miles. Toyota did replace transmission filter and torque converter at 102.000 miles and now we have 152.000 miles at this time, and now our 2nd gear is going out and the transmission needs to be replaced but can't found a rebuilt transmission. Due to back ordered parts. So what are we to do? The Rava4 is worthless without good transmission .Has there been any other related problems like this ? Toyota's are suppose to be good reliable cars.”

“The contact owned a 2014 Toyota Rav4. The contact stated while driving 25 MPH, it was noticed that there was smoke coming from under the hood of the vehicle, and the vehicle lost motive power. The contact arrived at the residence and the vehicle burst into flames causing the rear of another vehicle to melt. The fire department was able to extinguish the fire. A police report was filed. No one was injured. The vehicle was not towed or diagnosed. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was 120,000.”

“WHEN I FIRST BOUGHT THIS USED CAR WITH AROUND 90000 MILES IT STARTED VIBRATING WHICH LED TO DISCOVERING DRIVE SHAFT REPLACEMENT. ONE YEAR LATER IT NEEDS ANOTHER DRIVE SHAFT AT 118000. DOESNT GET DRIVEN MUCH IN WINTER. NOTICED CAR SHIFTED INTO A LOWER GEAR WHILE DESCENDING DOWN A STEEP HILL WHILE I WAS TRAVELING AT A HIGHER RATE AND HAD TO APPLY BRAKES QUICKLY TO MATCH THE LOWER GEAR. I FELT THIS COULD HAVE CAUSED A PROBLEM IN CAR HANDLING OR DRIVE TRAIN REPAIR. THE REPAIR IS EXPECTED TO COST $550 TO REPLACE THIS SECOND DRIVE SHAFT. PARTS DEALER SAID HE SOLD LOTS OF THESE. I THINK SOMETHING IS WRONG”