2016 Toyota RAV4 electrical system problems

“I was driving 9/3 and my left blinker light came on solid. I was not using my blinker. Within a few seconds my check engine light came on and another light. Then within 2 minutes the front left engine/tire caught fire.”

“The repair shop I was able to pull into as I was experiencing the issue with my vehicle reported: "Battery is unstable and is arcing off of the positive terminal. Battery tray, battery hold down tie, and battery j hook hold down were missing upon arrival." The issue was fixed by a Brakes Plus location, given I was able to pull in there - it was around the corner from where I was driving. The issue has been fixed, and I have no issue with inspection of the vehilce. The car died while I was driving on a main street. The recall note states that the vehicle could have caught on fire, though no fire or crash happened. I made a simple right-hand turn and almost every light imaginable illuminated on the dashbard. I was able to turn the vehicle off and on again and get the car to the Brakes Plus location. This location had to order the parts from Kansas. I called the Toyota Dealership informing them what had happened, that the car was unable to be moved and got the response that I needed to take it to them for repair. I called at least two times since I received the notice for the fix in the mail and I was told that I would be contacted when they were ready to fix my…”

“I called for a jumpstart for my truck after it cut off while I was turning onto a parking lot I hit a bump and it just cut off. I had to turn the truck completely off then start it again, after it started I made it completely onto the lot and parked it. When I went to start it again it wouldn’t turn over or startup. I used my State Farm app to request for a jumpstart or possible tow 2/23/25. On 3/9/25 the truck wouldn’t start again and I requested for another jumpstart. The engine light came on shortly thereafter saying that the AWD wasn’t available and that the FWD train was only available. I took it in for a battery replacement and that seemed to help for a couple of months, then my headlights started going out one at a time. The passenger side bulb went out first. I replaced it with a new one at Valvoline and then the driver side bulb went out two weeks or so later and I replaced it then the check engine light came back on and I eventually had to take into the dealership for repairs and maintenance. They said they fixed it. It worked for about a 12 days and then the headlights started dimming over time as the week went on the engine light came back on and…”

“Odometer Fraud. The contact purchased a 2016 Toyota Rav4. It was discovered that there was a mileage discrepancy. The vehicle was purchased from a private seller. At the time of the purchase, the mileage was 98,000. The vehicle was taken to an independent mechanic, and a Carfax report indicated that in November 2025, the mileage was reported at 170,000.”

“The contact leased a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) and requested to be removed from the recall distribution list because the contact no longer had the vehicle. The dealer and the manufacturer were contacted.”

“The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.”