2014 Toyota Sienna structure problems

“The passenger-side power sliding door system failed to stop or reverse when it encountered physical interference with the vehicle’s open fuel door. The door continued opening under power despite clear obstruction by a fixed exterior body component. The affected components, including the sliding door mechanism and damaged fuel door latch, remain available for inspection upon request. A powered sliding door continuing to operate against an obstruction creates a foreseeable risk of injury to occupants or bystanders, as well as vehicle damage. If a person’s hand, arm, or clothing had been in the same position as the fuel door, injury could have occurred. The incident occurred during normal vehicle use and demonstrates inadequate safeguards against obstruction. The issue has been formally reproduced or confirmed by an independent service center which noted that the incident occurred as described during normal operation of the power sliding door, and no abnormal conditions were present at the time. No warning lamps, messages, or other symptoms appeared prior to the incident. The power sliding door operated normally and without indication of malfunction until it…”

“The contact owns a 2014 Toyota Sienna. The contact stated that while driving 70 MPH, there was an audible alarm coming from the vehicle, alerting the contact that the door was ajar. The passenger’s side slide door opened independently while the vehicle was in motion. The vehicle was modified to accommodate a ramp for the contact's two wheel-bound children. The contact pulled over to the side of the road and closed the sliding door. The contact's husband tied the door to prevent it from opening independently again. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, where it was inspected. The contact was informed that two latches had corroded and needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 16V858000 (STRUCTURE). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,500.”

“The contact owns a 2014 Toyota Sienna. The contact stated while driving at various speeds, the contact heard abnormal sounds coming from the vehicle. The passenger’s side slide door became inoperable. No warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.”

“MY SON WAS GETTING INTO THE VAN VIA THE DRIVER SIDE SLIDING DOOR. HIS BACKPACK BUMPED THE SENSOR, AND THE DOOR OPENED AND FROZE HALFWAY OPEN. I DISENGAGED THE AUTOMATIC OPENING, BUT THE DOOR HAD DIFFICULTY CLOSING. I NOTICED THAT THE CABLE TO THE SLIDING DOOR HAD SNAPPED. I WAS EVENTUALLY ABLE TO CLOSE THE DOOR, BUT NOW THE DOOR WILL NOT OPEN AT ALL.”

“ON 12/20/19 IN MY 2014 TOYOTA SIENNA THE SLIDING DOOR NEXT TO MY 3 YEAR OLD OPENED WHILE I WAS DRIVING. I WAS IN THE MIDST OF ACCELERATING AFTER A LIGHT TURNED GREEN WHEN THE CAR STARTED NOTIFYING ME THAT A DOOR WAS AJAR AND THE PASSENGER-SIDE SLIDING DOOR STARTED OPENING. THE DOOR OPENED FULLY AND REMAINED OPEN AS I WAS AT SPEED IN THE MIDDLE OF AN INTERSECTION. NOTE THAT ALL DOORS WERE CLOSED AND LATCHED BEFORE I PUT THE VEHICLE IN DRIVE, AND THIS ONLY OCCURRED AFTER A FEW MILES OF DRIVING. I TOOK THE CAR TO THE DEALERSHIP AND THEY REPLACED THE LATCH ASSEMBLY IN BOTH SLIDING DOORS. THE DEALERSHIP COULDN'T TELL ME WHAT FAILED OR IF THE REPLACED LATCHES WOULD SOLVE THE PROBLEM, SO I CALLED TOYOTA CORP. I LEARNED THAT TOYOTA ALREADY KNEW ABOUT THIS ISSUE. WHEN I ASKED IF THEY COULD ASSURE ME THAT THE SLIDING DOORS WOULDN'T OPEN WHILE DRIVING AGAIN, THEY COULDN'T. THEY TOLD ME THAT THEY COULDN'T CONFIRM THAT THE LATCHES WERE THE PROBLEM, AND WHILE THE REPLACEMENT LATCH HAS A DIFFERENT MODEL NUMBER THAN THE ORIGINAL, THEY DON'T KNOW IF IT IS IN FACT A DIFFERENT PART AND IF SO, HOW. THE ONLY ASSURANCE THAT TOYOTA COULD GIVE ME IS THAT 'OF THE PEOPLE IN YOUR REGION…”

“TL* THE CONTACT OWNS A 2014 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S SLIDING DOOR FAILED TO FUNCTION WHEN USING THE POWER BUTTON. THE CONTACT HAD TO MANUALLY OPEN AND CLOSE THE SLIDING DOOR FROM THE EXTERIOR HANDLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V858000 (STRUCTURE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.”