2015 Toyota Sienna structure problems

“This is the 2nd Occurrence where Sliding Door Cable Breaks and the doors are disabled where you can not open or close the sliding door and its jammed shut. Attempts to press the Power Sliding door buttons do not work. This is the 2nd Occurrence on this Vehicle. The First occurrence happened approximately 3 years ago with the Driver Sliding Door and was report to Holman Toyota , 1301 NJ 73, Mt. Laurel township, NJ 08054. Now the passenger sliding door cable is broken and the door is jammed shut also”

“In August 2025, AutoNation Toyota on Sahara, checked the VIN of my Toyota Sienna and contacted Toyota while I was present. Toyota confirmed a broken fuel-door hinge was covered under a Customer Support Program. Instead, AutoNation attempted to repair, rather than replace, the hinge. This caused the metal fuel cap door to end up bent, paint to be gouged out from the bottom of the fuel door area, misalignment of the fuel door, and therefore issues with the door’s sensor reading correctly. I took the van back until they received shipment of a new fuel cap door. After the attempted repair, since the fuel door no longer aligned, the safety sensors repeatedly activated which strained the sliding-door ECU. The passenger sliding door began freezing intermittently, forcing my children to exit through the trunk several times. Finally, the door opened on its own as I was driving down the street. These issues did not exist prior to dealership service and presented a clear safety concern. Between October and December, I received conflicting explanations from Gerald, James, Ivan, and Rudy at AutoNation Toyota regarding whether the issue involved the fuel door, ECU, motor, or…”

“Fuel filler door upper hinge failed so that door would not seat properly when closed. Because the door was not seated properly, the left side power sliding door interlock did not release, preventing the sliding door from opening fully. I had visited a fast food restaurant in Feb 2025 and ordered some French fries for my[XXX], strapped into his child seat directly behind the driver. He was choking on a fry, starting to turn blue. I quickly stopped and attempted to open the sliding power door, but it would not open fully to allow access to my grandson because the failing fuel door wouldn't release the power door interlock. By the time I ran around to the passenger side to reach him he had nearly passed out, but I reached him in time to extract him from the seat and performed a Heimlich to expel the fry and restore his breathing. Toyota should be forced to extend the extended warranty for the full duration of the court agreement of 10yr, Dec 2025, regardless of purchase date. My request for fuel door replacement in Jul 2025 was refused because Toyota claimed the warranty was only good until 10yr after date of purchase, not to the end of 2025. The warranty period…”

“The contact owns a 2015 Toyota Sienna. While the vehicle was parked, the contact discovered that the fuel lid door hinge had fractured, causing the fuel lid to intermittently fail to open or close as needed. The contact stated that with the fuel lid intermittently inoperative, the rear driver’s side door failed to open when needed. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was determined that the fuel lid door and hinge needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 117,000.”

“Cable that controls sliding door broke. Door now pops open about 1cm, not enough that you notice that it is open and when you drive it slides open more. It also can't be closed with the button and it's not easy to close.”

“THE CABLE TO MY SIDE POWER PANEL DOOR SNAPPED YESTERDAY. IT IS HANGING FROM THE SIDE OF MY CAR - WHAT DOESN'T SEEN RIGHT IS THAT THE CABLE IS RUSTY - IT LOOKS LIKE IT SNAPPED BECAUSE IT IS WAS EXPOSED TO MOISTURE. THE DOOR IS COMPLETELY UNUSABLE - I CANNOT OPEN IT USING THE MANUAL OR POWER MODE. MY VAN IS IN MY TEMPERATURE CONTROLLED GARAGE THE MAJORITY OF THE TIME AND THERE SHOULD BE NO REASON THAT THE CABLE IS SHOWING SIGNS OF RUST OTHER THAN A DESIGN FLAW.”