2008 Toyota Tacoma suspension problems

“Toyota Corporation refuses to replace the frame and other essential parts on our 2008 Toyota Tacoma, which has had 2 previous recalls for frame replacement. We were never made aware of the previous recalls by Toyota or it's dealer who sold us the truck. We were made aware of the serious condition of the frame when our mechanic personally inspected the vehicle and notified us that the frame needed replacement. Toyota refuses to inspect or acknowledge the unsafe condition of our truck frame. Photos supplied speak for themselves. Our Toyota Case # is XXX has resulted with no benefit or consideration from Toyota. Therefore we request #XXX Request for NEW recall. Our mechanic [XXX] informed us the local Toyota dealer (Lithia Toyota Missoula) and it's parent company are notorious for not informing owners about recalls. We were never told when we bought the vehicle used that there was a previous recall. Also, two years after our purchase we just learned there was a follow-up frame recall, which nobody informed us of it's existence. We are sure the NHTSA does not want this vehicle in service on the road. So, again, please issue another follow-up recall for full frame…”

“The brakes on my 2008 Toyota Tacoma were failing so I took it to a mechanic, who said that the brake lines had failed and needed to be replaced. However, he said that it wasn't worth putting any money into the truck, as the leaf springs were corroded along with the frame, which could crack apart at any time. As we only purchased the truck one year ago, he advised us to take it to the dealership where we purchased it, and informed us of the recalls on both of these issues. I spoke with the mechanic at the dealership because when we purchased the vehicle, they did the inspection and said that everything was fine. When I asked the mechanic about this, he said that he didn't have anything to do with sales and we needed to speak to the owner (who is out on medical leave). The mechanic said that when the dealership purchased the vehicle at auction, the frame must have been undercoated and so they missed it. When I mentioned the recall, he told me to call Toyota. I have checked the VIN and it is not showing an open recall for this vehicle. However, it is experiencing the exact same safety issues as the recalls for leaf spring corrosion and frame rust and cracking. I…”

“Toyota has had a long history of excessive frame rust. This truck has excessive frame rust. There was a recall to fix this frame rust and my truck has not been fixed. Toyota will not fix the current recall for the spring replacement because of the frame rust. My life and my children’s lives are in danger due to the possible leaf suspension failure that may puncture the gas tank.”

“Hope to be able to get this solved. My 2008 Toyota Tacoma had a recall with the previous owner but they didn't take it in. On the rear section of the frame on the inside beside the gas tank and on the driver side there is a lot of rust there the frame has expanded and is starting to go all away through also same place back beside the muffler on the passenger side. Also there are a few spots on the front part of the frame under the fire wall area on both sides. I had a recall on the truck and took it in and had it fixed which Toyota replaced the leaf springs on both sides and hardware. Says there was a recall when the previous owner had the truck. Will they validate that still? I've owned the truck almost a year now. But it's getting worse. Within a year I'm gonna have to park it because it liable to possible break in half. Toyota should of let me known when they had it on the lift replacing the rear leaf springs. Not my fault the previous owner didn't take the truck in to have them look at it.”

“In March of 2008, I purchased a new 2008 Toyota Tacoma (VIN: [XXX] ) from Orleans Toyota in Massachusetts. In July 2010 I re-located to New Hampshire and registered the vehicle in that state in July 2010 where I have resided since. The odometer reading at that time was 21,220 Miles. In September of 2014, I received a safety recall notice from Toyota regarding a potential frame corrosion problem. I scheduled an appointment with the local Toyota dealership in East Swanzy NH on September 12, 2014 to address this issue. The odometer reading at the time was 82,068 miles. There were two remediation options, as set by Toyota: A.Inspect frame, clean, and apply CRC if no perforations were found B.Inspect frame and if perforations found, replace the frame. Both of these options were intended to mitigate any and all risk of future corrosion of the frame that was a result of a known vehicle design flaw. Toyota chose to apply the CRC. I therefore assumed that the frame was intact at that point in time and the issue had been resolved. Between September 2014 and December 2019, I drove the vehicle 62 miles a day on [XXX] in NH commuting between Hillsboro and Keene for all 12…”

“Tried to avoid a deer and the frame of truck felt unstable and felt like it was folding. I looked at the frame there are rust holes through out the whole frame. How could they design this and not back it up.”