2000 Toyota Tundra engine and engine cooling problems

“I HAD A RECALL LETTER FROM TOYOTA REGARDING FRAME RUST. IT WAS TO BE DONE AT NO CHARGE. WHEN THE DEALER INSPECTED THE FRAME, THEY SAID THE TRUCK QUALIFIED FOR FRAME REPLACEMENT AT NO CHARGE. WHEN THE WORK WAS BEGINNING, HOWEVER, I RECEIVED A PHONE CALL STATING NUMEROUS PARTS HAD TO BE REPLACED BECAUSE THEY WERE DESTROYED DURING THE FRAME REPLACEMENT PROCESS. I WAS TOLD IT WAS NOT NEGOTIABLE AND I WOULD HAVE TO PAY FOR THEM. THESE INCLUDED ALL SHOCKS, TIE RODS AND ENDS FOR $350. ALSO, THEY SUGGESTED REPLACING THE STEERING RACK AND RADIATOR CAP FOR AN ADDITIONAL $650. I HAVE CONTACTED TOYOTA CORPORATION TO TRY TO GET THE REAL STORY OF WHAT IS COVERED AND WHAT MAY NOT BE COVERED. *TR”

“I HAVE A 2000 TOYOTA TUNDRA AND IT HAS A PROBLEM THAT WHEN THE CAR GETS HOT THE ENGINE WILL STALL OUT AND DIE WITHOUT WARNING. IT CREATES NO OMD II ERRORS AND THE CHECK ENGINE LIGHT NEVER APPEARS. THE ECM FUSE BLOWS ON OCCASION BUT REPLACING IT DOES NOT LEAD TO A RUNNING VEHICLE. IT FAILS TO START UNTIL THE ENGINE COMPARTMENT COOLS DOWN. THERE IS FIRE FROM THE SPARK PLUGS AND THERE IS FUEL PRESSURE IN THE FUEL RAIL. WE HAVE REPLACED ALL THE RELAYS AND FUSES IN THE ECM AND EFI CIRCUITS AND ALL FINGERS ARE NOW POINTING TO THE ECM CONTROLLER ITSELF. WE JUST CHANGED OUT THE FUEL PUMP AND ARE LOOKING AT REPLACEMENT OF ALL THE IGNITION COILS (8) AND ALL THE FUEL INJECTORS (8). BUT SINCE ALL OF THESE COMPONENTS SEAM TO BE WORKING THAT WOULD MAKE LITTLE SINCE. THE RECENT RECALL FOR THE ECM ON THE MATRIX & COROLLA INDICATE THAT THERE MAY HAVE BEEN PROBLEMS WITH THE MANUFACTURE OF ECM UNITS FOR A MUCH LONGER PERIOD OF TIME SINCE MY TUNDRA IS EXHIBITING THE SAME PROBLEM. THIS PROBLEM HAS BEEN GETTING WORSE FOR OVER 5 YEARS NOW AND THE TOYOTA DEALERS AND OTHER TOYOTA SPECIALTY SHOPS CANNOT FIND THE PROBLEM SINCE THERE ARE NO ENGINE CODES AND THE FACT THAT IT WILL START AND…”

“I HAVE A 2000 TUNDRA ACCESS CAB TRUCK WITH 62,000 MILES. THE CHECK ENGINE LIGHT CAME ON SO I HAD IT DIAGNOSED. THE FRONT O2 SENSOR BEFORE THE CAT HAS FAILED. I WROTE TOYOTA AND THEY SAID THAT THEY HAD EXTENDED THE WARRANTY TO 7 YRS OR 90,000 MILES. THEY SAID THAT IT WAS ALSO UP TO THE LOCAL DEALER TO DECIDE IF THE FAULT WOULD BE COVERED. I PURCHASED THIS VEHICLE FROM A RELATIVE, WHO IS NOW DECEASED, AND DID NOT RECEIVE ANY RECALL INFO. I WROTE TO TOYOTA AND THEY TOLD ME TO TALK TO MY LOCAL DEALERSHP. I TALKED TO THE LOCAL DEALER AND THEY TOLD ME TO WRITE OR CALL THE TOYOTA EXPERIENCE DEPARTMENT, OR WHAT EVER IT IS. FROM WHAT I HAVE READ THERE ARE A LOT OF PEOPLE GETTING RIPPED OFF FOR A DEFECT IN FACTORY PROVIDED PARTS AND REPLACEMENT PARTS. I DEFINATELY THINK THIS IS A DESIGN FLAW AND SHOULD BE COVERED BY TOYOTA. I FOR ONE CAN NOT AFFORD TO OWN A VEHICLE THAT IS GOING TO COST $200.00 TO $800.00 EVERY 6 MONTHS TO 2 YEARS. THIS ALSO AFFECTS THE ENVIRONMENT AND THE FACT THAT THIS VEHICLE HAS TO BE SMOGGED EVERY 2 YEARS.”

“TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. DURING ROUTINE MAINTENANCE A TECHNICIAN DISCOVERED THAT THE ENTIRE FRAME WAS CORRODED. THE VEHICLE HAS NOT BEEN INSPECTED OR REPAIRED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 139234. UPDATED 11/06/09 *BF ALSO THE CHECK ENGINE LIGHT WAS ON. UPDATED 11/09/09*JB”

“AT 80,000 MILES MY TRANSMISSION NEEDS TO BE REPLACED . I HAVE NEVER ABUSED THIS VEHICLE IN ANY FORM AND FEEL THAT TOYOTA SHOULD REIMBURSE THE MANY THOUSANDS OF OWNERS WHO SEEM TO BE HAVING THE SAME PROBLEMS WITH THIS MODEL. FOR THE AMOUNT OF MONEY THESE VEHICLES COST IT ONLY SEEMS FAIR THAT TOYOTA SHOULD BE FORCED TO STAND BEHIND THEIR PRODUCTS. *TR”

“BOTH LEFT AND RIGHT EXHAUST MANIFOLDS ARE CRACKED AND LEAK EXHAUST GASES INTO PASSENGER COMPARTMENT. RIGHT EXHAUST MANIFOLD HAS BEEN REPLACED. BECAUSE OF COST, LEFT EXHAUST MANIFOLD HAS YET TO BE REPLACED. *TR”