2003 Volkswagen Jetta seats problems

“WHEN THE SEAT HEATER IS TURNED ON, THE SEAT CATCHES ON FIRE. WHEN YOU LOOK AT THE PICTURE THAT IS SMOKE COMING FROM THE SEAT, THE HOLES WERE CAUSED BY THE SEAT HEATER.”

“WHEN I WAS SITTING IN THE DRIVER'S SEAT WITH THE HEATED SEAT OPTION TURNED TO A 5 (HIGH), WHILE THE CAR WAS WARMING UP, I NOTICED SOME SMOKE COMING FROM THE RIGHT SIDE OF THE SEAT. THE HEATED SEAT STARTED TO BURN THROUGH THE CLOTH COVER DIRECTLY WHERE MY METAL JACKET ZIPPER WAS MAKING CONTACT WITH THE CLOTH SEAT SURFACE. I IMMEDIATELY POURED WATER ON THE SEAT TO ENSURE A FIRE DIDN'T START. I HAVE NOT ATTEMPTED TO USE THE SEAT HEATERS SINCE THIS INCIDENT.”

“THE RIGHT AREA OF THE DRIVER'S SIDE HEATED SEAT BEGAN TO GET EXCESSIVELY WARM SO I DISCONTINUED USE FOR A PERIOD OF TIME. SUBSEQUENT ATTEMPT AT USE RESULTED IN THE HEATING COIL BURNING THROUGH THE UPHOLSTERY. PICTURES ATTACHED. I HAVE DISCONTINUED USE AND LEARNED THERE IS AN EXPIRED RECALL FOR THIS AS A KNOW ISSUE.”

“DRIVER SIDE SEAT HEATER GETS VERY GOT. ON MARCH 4, 2016 AT 7:30AM NOTICED A BURNT SMELL AS I PARKED MY CAR (I HAD DRIVEN FOR ABOUT 20 MINS). WHEN I RETURNED AT 12PM FOR LUNCH, I NOTICED 2 BURNT AREAS OF MY LEATHER SEAT. MARCH 5TH, TRIED TO USE HEATER AGAIN BUT WITHIN 10 MINS IT GOT TOO HOT TO TOUCH AND BURNT SMELL, REALLY BAD. I SHUT IT OFF. I CAN'T USE THIS NOW. VERY DISAPPOINTED.”

“SOMEONE LEFT THE PASSENGER SIDE SEAT HEATER ON. I STARTED SMELLING A BURNING PLASTIC ODOR THEN I CAME ACROSS A SMALL BURN MARK. ANOTHER PERSON LEFT IT ON, THE WHOLE BECAME BIGGER BUT NO SCENT.”

“TL- THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH A BURNING PLASTIC ODOR WAS PRESENT INSIDE THE VEHICLE BEFORE THE PASSENGER SUDDENLY EXPERIENCED A BURNING SENSATION COMING FROM THE SEATED AREA OF THE PASSENGER SEAT. THE CONTACT INDICATED THAT THE PASSENGER SIDE SEAT HEATER ELEMENT HAD OVER HEATED CAUSING A BURN HOLE IN THE SEAT AND CAUSING A MINOR BURN TO THE PASSENGER. THE CONTACT STATED THAT A SMALL FLAMED TO THE PASSENGERS RIGHT PANT LEG HAD TO BE EXTINGUISHED DURING THE INCIDENT AND THE PASSENGER SEAT BURN HOLE MEASURED APPROXIMATELY 1 INCH IN DIAMETER. THE VEHICLE WAS DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE DEFECT WAS CAUSED BY A FAULTY HEAT ELEMENT INSIDE THE SEAT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 125,000. JFT”