2019 Volkswagen Jetta fuel/propulsion system problems

“It will not take fuel. I try very slowly to put fuel in it and it keeps shutting off at the pump. I took it to the VW Dealership and they said it was a stuck valve in the tank. That I would need a new gas tank and wanted to charge me $2000 to fix it. I took it to another place and they said it was a venting problem. They put a camera down in the tank and pushed the stick valve open and it wasn’t stuck as much as it had pressure built up in the tank from not getting holding the valve shut. I’m not sure what to do. I don’t know if it’s a stuck valve or a venting problem.”

“VIN: [XXX] Previous Report: XXX.. This a report of a continuing problem with my vehicle. The engine randomly shuts down endangering both myself and my passengers who are often my [XXX] and [XXX] grandchildren . No warning lamps. the car both stumbles and stops while driving and at stop signs and traffic lights. I repeatedly have taken it to my dealer (Elgin IL VW) they have been unable to determine the fault and fix it. This has been going on since June 2026 and progressively worsened. The most recent incident was on the afternoon of 19 June 2026. The “fixes’ so far have included bith replacing the fuel taknk fuel pump and today a part of the fuel feed system. It’s still at the dealership.”

“My 2019 Volkswagen Jetta cannot be refueled — gas nozzle clicks off instantly or overflows. The check engine light came on, and VW Corporate confirmed code P00FE, indicating a failure of the EVAP system vent valve. This is a sealed emissions component integrated with the fuel tank. Dealership initially claimed there were “no codes,” but a video shows their technician confirming the EVAP code, disconnecting the EVAP system, and concluding the tank must be replaced. However, since the valve is a powered solenoid, unplugging the system wouldn't allow it to open — this invalidates their test and diagnosis. VW has denied warranty coverage even though the issue clearly falls under the 8-year/80,000-mile federal emissions warranty as defined by the EPA and VW’s own documentation. I also discovered they misrepresented an active recall (#28H7) and falsely told me I had none. VW Customer Care told me about the recall and informed the dealership. VW Customer Care informed me 7/9/25 that the recall had been repaired. Carfax yesterday and your system today show that it still has not been repaired. This is a safety hazard. I cannot refuel reliably, and the dealership is…”

“fuel actuator failed not allowing gas door to open on a 12 degree night traveling on a highway going home which is a common problem with these vehicles. luckily, we drive slow and had enough fuel to get home . i think this qualifies as a safety issue.”

“I had a recall on a fuel pump in the previous years. After that, if I was trying with about half a tank of gas and let’s say speeding up to get on the highway, the car EPC light would come on and say can’t go over 4000 rpm . Then my car would speed would be so slow. I told the dealership about this before. Heard nothing. It is dangerous because I can’t speed up going onto the highway. Now this it happens when the gas is a lil more than half a tank. My car will slow down when speeding up . Almost feels like a jerk back and sounds like it. Sounds like something is gonna break and drop out of my car. I try to keep my gas up to avoid this but mostly I can’t. Ever since the pump got repair and covered by warranty/recall.. this is what happens. I slowly have to accelerate and speed up my car . Now I have a canister purge leak from a hose crack and I have read recalls but it doesn’t have my affected. I believe all of this goes together and the dealership should be paying for this. Also, the EPC light does turn off once I stop somewhere and turn the car off and I turn it back on without even refueling the tank”

“I was driving and the and the stop start error came on, smelled gasoline and the EPC and check engine lights came on. I kept driving because we were on the freeway and couldn’t quite stop there but my car automatically turned off. The lights stayed on. I was able to turn it off after a few tries and get it to the mechanic (with it turning off a couple times on the way there). After diagnosis, they stated that it is the fuel injectors that need to be replaced because the gasoline and oil are mixing and thinning out the oil as well as potentially cause a fire. Due to that, i now need to replace the spark plugs and replace the oil as well as all 4 fuel injectors. I checked with volkswagon and they stated my car is not on a recall list but I did see there was a recall previously for the fuel injectors. Even if my car is not on the list, this is literally hazardous. The mechanic sent me a video of the oil mixed with gas firing up.”