2004 Volkswagen New Beetle power train problems

“DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT…”

“TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.”

“2004 BEETLE WITH 85,000 MILES HARD SHIFTING DOWN - IT JERKS FROM GEAR TO GEAR UNTIL IT COMES TO FULL STOP. . NOW WHILE UPSHIFTING IT COULDN'T MAKE IT OUT OF 3RD GEAR AND HAVE ALMOST BEEN REAR ENDED 3 TIMES. CAR JERKS ,SHUDDERS, LURCHES . TRANSMISSION PROBLEM IS CONSISTENT WITH LOW MILEAGE VW BEETLES”

“I BOUGHT THE NEW BEETLE NOT EVEN A MONTH AND I NOTICED A JERKING IN THE TRANSMISSION. I FOUND OUT USING SPECIALIZED WEBSITES FOR ENTHUSIASTS THAT VOLKSWAGEN ISSUE LETTERS TO OWNERS OF NEW BEETLES IN 2010 INFORMING THAT TONS OF OWNERS COMPLAINED ABOUT THE HARD SHIFT THEY WERE EXPERIENCING IN THE AUTOMATIC TRANSMISSION OFTHEIR NEW BEETLE. VOKSWAGEN OFFERED TO EXTEND THE WARRANTY ON THE TRANSMISSION VALVE BODY. THE MODELS AFFECTED SPANS FROM 2003 TO 2008. IN OTHER WORDS, VOLKS SOLD FAULTY CARS WITHING THIS TIME RANGE AND ONLY RECOGNIZED LATER IN 2010 ABOUT THE ISSUE. HOWEVER, THE VALVE BODY FAILURE IN THE TRANSMISSION IS ACROSS THE BOARD AND A RECALL SHOULD HAVE BEEN ISSUED FOR THE RANGE OF 2003-2008. THE COMPONENT WAS DESIGNED TO FAIL BY DESIGN. NOT EVEN THE REPLACEMENT WOULD FIX IT BECAUSE IT WOULD HAPPEN AGAIN. IMAGINE THE DANGER WHEN THERE IS A HARD-SHIFT AND THE CAR STARTS TO JERK AND CHANGING GEARS ERRATICALLY ? IMAGINE THIS HAPPENING ON I95 OR ANY OTHER HIGHWAY. VW JUST EXTENDED THE WARRANTY BUT A RECALL IS NEEDED HERE. I CALLED VW AND THEY ARE REFUSING TO FIX IT SAYING IT IS AN OLD CAR AND WARRANTY IS EXPIRED, BUT THE TRUTH IS SINCE 2003 THE HARD SHIFT…”

“TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FELT AS IF IT WERE IN NEUTRAL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR SHIFTER IN PARK AND THEN BACK INTO DRIVE, AND WAS ABLE TO RESUME DRIVING. THE CONTACT STATED THAT SHE HAD TO REPEAT THE SAME PROCEDURE FIVE TIMES UNTIL SHE REACHED HER DESTINATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PERRYSBURG AUTO MALL (26875 N DIXIE HWY, PERRYSBURG, OH 43551, PHONE NUMBER: (419) 874-4331) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.”

“THE GEARBOX SLIPS, STUTTERS AND JERKS . AND WILL SLIP OUT OF GEAR AND NOT GO BACK IN GEAR UNTIL ENGINE IS RESTARTED. THIS HAPPENS WHEN STARTING TO MOVE FROM A STOP.”