2010 Volkswagen Routan electrical system problems

“The contact owns a 2010 Volkswagen Routan. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. In addition, the contact stated that the turn signal and the speed control failed to function as designed. The vehicle was taken to an independent mechanic. The failure was troubleshooted; however, the failure was not diagnosed. In addition, the vehicle was taken to the dealer, and the failure was not diagnosed. The contact stated that neither the independent mechanic nor the dealer was able to diagnose or determine the cause of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that after researching, the vehicle was known for electrical system failures. The contact referenced an unknown recall with a similar failure description; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was unknown.”

“The contact was helping her friend who owns a 2010 Volkswagen Routan. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact stated that the check engine and stability control warning lights were illuminated. The contact stated that the failure was a recurring failure. The contact had taken the vehicle to a local dealer and was informed that the vehicle was built by another manufacturer. The contact was then referred to another dealer. The contact was advised by the 2nd dealer that the vehicle should be taken back to the first dealer. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 11V151000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 100,000.”

“On 01/24/25 around 9pm I was leaving a friend house headed home. I took the i76 route home because it's faster. As I'm getting off on my exit, coming up on the first stop sign I start pressing down on the break pedal and all of a sudden the car engine shuts off and comes to a sudden seizure like halt. I put on my hazards lights instantly, put the car in park and proceeded to to start the car again. After like 10 failed start attempts. I decided to give it a rest and that's when I realized that there key would not come out the ignition, I had to turn the ignition back and forth twice before it was released. After that I waited about 25 minutes, and have it another shot but this time I stepped on the gas while attempting to start the car and it came back on. I went home parked and since that day the car won't turn over but everything still comes on. There are no codes, showing, no damage to the car at all it's still pretty much new. Vw says there nothing they can do because my vin is not on the recall list but I'm literally experiencing the same mechanical issued that are listed on the recall for my exact model. Can someone please offer me a solution that doesn't…”

“I bought this van just a few weeks ago. One day I was driving and all a sudden it lost power while in motion. This has happened 4xs so far. It could've resulted in the inability to stop my vehicle as the brakes are stiff after the power & engine stop working. It could've resulted in either I hit someone or someone could've hit me. My cousins husband had a town and country that did this & it was on a recall for the ignition switch failure. He's a mechanic. He has also stated what is going on is the ignition switch failure going into accessory mode while I'm driving. It's available to be inspected I just don't have the money to have it inspected at this point by a dealership.”

“Battery failure due to parasitic draw from Ignition IOD fuse ( J13fuse) reads 0.9 draw and M11 fuse ( hvac system) reads 0.6 draw. First occurrence 2/10/24 and second occurrence 2/11/24. Informed auto repair shop on 2/12/24 and goes in for diagnostic 2/15/24. Abs control module failure( intermittent ) Egr valve replacement (8/9/24 due to overheating but no warning lights due to overheating was displayed which is strange) Speed control sensor was replaced as well 8/9/24 but still has problems getting stuck or not reading the right speed . Consumes fuel faster than normal as well . Getting about 9 miles to the gallon.”

“All electrical gauges randomly go on and off, there is a continuous beeping to go along with it, the windshield wipers will go on and off. It seems to happen more in the summer or if it’s raining. It will occasionally stall while doing this, especially in a stationary position (like at a drive through).”