2021 Volkswagen Tiguan engine problems

“The high pressure fuel pump has failed within 40,000 miles and now again at 110,000 miles. It causes the vehicle to randomly turn in drive and while idle. It has had oil consumption issues and oil leak issues that constantly occur. The dealer has replaced the high pressure fuel pump under warranty 40,000 miles and has now detected it needs to be replaced again at 110,000 miles. I paid for oil leak repair which was over 5,000 dollars and now I have another oil leak issues with the oil separator.”

“At 58,218 miles, the engine on this 2021 Volkswagen Tiguan failed after excessive oil consumption progressed to engine knocking. The vehicle was brought to Volkswagen of Orange Park on July 24, 2025, for excessive oil consumption. The dealer performed a second oil-consumption test. During the test, the engine was heard knocking. The dealer removed the oil pan and found excessive metal. Volkswagen replaced the engine under warranty. The repair invoice was dated August 31, 2025. This created a safety concern because an engine failure can cause loss of propulsion or stalling while driving. The dealer confirmed and repaired the condition.”

“At approximately 53,876 miles, my 2021 Volkswagen Tiguan experienced a severe, premature failure of the Positive Crankcase Ventilation (PCV) valve / oil separator assembly. The failure of this component caused an immediate, dangerous buildup of internal crankcase over-pressurization. Because the excess pressure could not vent safely, it caused a catastrophic domino effect through the engine block, structurally blowing out multiple critical engine gaskets and rubber oil seals. Furthermore, the extreme downward pressure physically cracked the factory-installed composite plastic oil pan, leading to an immediate and rapid engine oil leak. A sudden and rapid loss of engine oil and internal oil pressure while operating a vehicle at highway speeds poses an extreme safety hazard. Had the oil pressure dropped completely while driving with my children in the vehicle, it could have resulted in a sudden engine seizure, sudden loss of motive power, or complete engine failure on a live highway, placing my family and surrounding drivers in imminent danger of a high-speed collision. Volkswagen is aware of this engine design defect, as evidenced by active internal Technical…”

“Like many others, at 55k miles, our oil separator malfunctioned causing our oil pan to crack and dump every drop of oil. We had to replace the oil pan and fortunately our mechanic friend figured out it was the new pcv valve malfunction causing too much pressure in the engine. My wife was luckily pulling onto our property when the car essentially shut itself off. When searching for the valve I needed, talking to multiple parts dealers and then a vw tech, none of them are sure why there’s no recall. It happens between 50-60k to THOUSANDS of people now. Then I watched videos on the issue and the mechanics online are all saying the same thing- this should’ve been a recall 2 years ago and are all asking the same question. It’s time VW does what’s right. It’s awfully coincidental that they installed plastic oil pans that would crack and leak under instead pressure, rather than a blowout seals because of the valve failure.”

“Taking left turns is dangerous. My turn very slowly and Hard press on pedal to turn. Oil consumption is insane. Started at 38k miles, manufacture warranty ended after 4 years. I’m under 52k miles now and have to fill oil about every 1k miles. I’ve had 4 oil changes this year alone. I’m regular about Maintenence. Last oil change was 08/03/26 check oil light came on 8/15 had to add 3.5 quarts 8/26/26 Will keep track of each time I need to add oil and update here. This has been an issue for many Tiguan owners where is the recall???”

“Noticed the check engine oil light started coming on periodically between oil changes 3-4 years ago, but no external or noticeable oil leaks. Was told by VW multiple times it’s standard for VWs to burn oil. I started having to top off oil much more frequently over the last year, 1 quart per 1000 miles. The check engine oil light would turn on every month at random times while driving. Took my car to a shop; they removed 02 Sensor 1 and borescoped the exhaust system. Found oil leaks from valve seals, leaking into the exhaust manifold. A few weeks later, the check engine light came on for the first time (codes: P24D6 and U3501). Brought car to another shop; they scanned the car and the following codes were found: U350100 (Passive/Sporadic) - Control Module Input Power "A" Circuit Low U041600 (Passive/Sporatic) - Invalid data received from vehicle dynamics control module) P003000 (Passive/Sporatic) - O2 Sensor Heater Control Circuit Bank 1 Sensor 1 U105400 (Passive/Sporadic) - Information electronics 1 control unit No communication P24D600 (Passive/Sporadic) - Evaporative Emission (EVAP) system pressure sensor/switch B circuit range performance. The second shop…”