2019 BMW I3 problems

“The car has lost power on the highway multiple times and gone into Limp mode with no warnings on the dashboard. The Rex engine has failed to start as well. Very dangerous on the highway going 20 mph trying to make the next exit. The car has been back to the BMW dealer multiple times (over 2.5 months at the dealer ) with no repair. They are now offering to take the car in trade. The car is still under the EV warranty in California. Seems they and BMW engineering don’t know how to repair the car and are now putting the burden on the consumer.”

“This is an electric vehicle. I experienced a sudden loss of all power while traveling on the interstate in heavy traffic. I nearly lost control of the vehicle as it would not respond to my inputs. I had to cross two lanes of dense interstate traffic to get to a safe area to pull over and it was terrifying because the car just suddenly shut down while traveling at highway speeds. The dealership that I had the car towed to did some diagnostic work and said that "EME" had failed. The EME is the main processor that controls all electrical functions in the vehicle. My understanding is that 2019 BMW i3's were recalled due to failures of the EME due to corrosion. How my car was missed in that reacall, I can't ascertain. Perhaps because my particular car has an "S" designation, so it is called an "i3S" and it slipped through the cracks on the original recall. At any rate, the failure was catastrophic; it could have caused an accident and killed me. The car lost all power at highway speeds. Please look into why the i3S was overlooked in the original recall.”

“The drivetrain system malfunctioned while increasing from 60 MPH to 70 MPH. The vehicle lost all propulsion mid-journey. This put myself as well as other drivers around me at risk while I coasted to a stop on the freeway. The vehicle's warning system stated: “Drivetrain Malfunction: Stop carefully and turn off engine. Do not continue driving. Call Roadside Assistance.” There are error codes that were considered by the manufacturer's nearest service center. And while certain reduction in efficiency of the High Voltage battery were identified, the vehicle was re-initialized and test-driven multiple times, successfully moving of its own power. Notably, the vehicle's battery capacity was noted to be at 70%, not below the federally-mandated capacity for manufacturer-covered repair.”

“On July 4, 2021, I realized that the charge port on my BMW i3 would not accept a charge plug - it appeared to be blocked. I took the car to the dealer and they informed me that the charge port had been damaged (melted) by heat from a defective charger. In addition to public charging, I had typically been using a home charger - a MUSTART Level 2 40-amp charge cable purchased from Amazon on February 4, 2019. The BMW technician requested to see the cable and it was confirmed to be damaged also. BMW attributed this incident to the charger rather than the vehicle, so the repair (over $2400) was not covered under warranty. I feel this represents a serious safety concern, as the overheated charger/charge port could have caused a fire in my garage. I have retained the parts associated with this incident, including the charge cable and the damaged charge port from the vehicle.”

“In early September, a "driver retention system" error appeared the dash display of my '19 i3. I searched the issue on line and tried but failed to resolve it. A few weeks later, the seat belt alarm stopped going off when the belt was clasped. At this point, I had no choice but bring it in for a fix. The dealer advised that there would be a $305 fee to diagnose the problem. They found a faulty belt buckle that failed in normal use. To fix it was going to cost another $805.22 to replace the buckle. I had no choice but to authorize this work. I believe safety related equipment should be covered by the manufacturer, beyond the normal warranty for a minimum of 10 years. Using AI, i find conflicting information about who is responsible for safety equipment when it fails. I am writing this to find out the NHTSA regulation that covers this, so when I call BWW customer service for an accommodation or hopefully, a full refund, I have all the information I need to plead my case. Thank you! Bob H.”