2023 Chevrolet Bolt Euv problems

“Was initially stopped at a red light heading northbound while in the right turn lane. The cross street had two lanes of traffic heading in each direction separated by a median divider to the west and a left turn lane to the east. After cross traffic cleared from the nearest eastbound lane, but cars continuing to travel in the far eastbound lane, I began a ‘right turn on red’ into the nearest eastbound lane. Somewhere near, but short of completing the entire 90° turn, the AEB system violently slammed on the brakes causing strong vibrations like I had hit or been hit by another car. My estimated speed at the time was approx. 15 mph. Not positive, but I believe the collision alert beeped and red dot HUD activated at the same time indicating an impending collision. Believing I had been hit, I think I applied the brake pedal to ensure the vehicle completely stopped rolling. After visually checking my surroundings, I saw no other vehicles, pedestrians, or objects anywhere near or around my vehicle. Concerned I had possibly run over something instead, I slowly proceeded forward to visually check the road surface to see if anything was in the road behind. The vehicle…”

“What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle displayed a Service ESC warning, indicating a possible malfunction in the electronic stability control system. I have had difficulty reproducing the issue, but the vehicle and any related components are available for inspection upon request. How was your safety or the safety of others put at risk? The malfunction may have reduced the vehicle’s stability and traction assistance, which could increase the risk of losing control while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? I have taken the vehicle to the dealer three times. The first time, the dealer replaced the battery. The second time, the dealer installed a software update. The third time, they were unable to reproduce the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by the dealer. No inspection by police, insurance representatives, or other third parties has occurred. Were there any warning lamps, messages or other symptoms of the problem…”

“The electric power steering / steering gear assembly exhibits mechanical binding ("sticky steering") and completely fails to return to center. When going around a curve in the road, the steering wheel "memorizes" or holds the turned angle and will not unwind or self-center like it used to and as I would expect it to. I'm having to apply continuous, deliberate manual counter-steering to bring the vehicle back to straight. The steering also has a distinct "notchy" or sticking sensation when making small steering adjustments that make clear audible clicking or knocking sounds at lower speeds. The issue began intermittently from my recollection around early 2026 and has grown progressively worse. It's most certainly progressed to feeling like a serious safety hazard by potentially causing significant driver fatigue, over-correction, and difficulty maintaining lane discipline, increasing the risk of lane departure or an inability to complete emergency evasive maneuvers. I will have a teenage driver soon and would not feel comfortable with her driving this vehicle in its current state. I verified that all "driver assistance" features were disabled and were not the…”

“While car was on a warning popped up saying "Service Transmission" and then another warning popped up saying "Propulsion Power is Reduced". This then limited the speed of the car and the acceleration significantly making it extremely unsafe to drive. Thankfully I was not on the interstate, but I certainly would have been hit if I was. This car is less than 2 years old, has under 10,000 miles, and his had all recommended maintenance done.”

“Water intrusion occurred inside the rear taillight assembly, resulting in visible moisture/condensation within the housing and subsequent taillight malfunction/failure. The affected taillight performs critical rear lighting functions, including brake and signaling illumination. The presence of water inside the sealed taillight assembly indicates a failure of the lens or housing seal. Over time, moisture intrusion caused degradation and failure of the lighting function. Loss or impairment of rear lighting reduces the vehicle’s visibility to other drivers, particularly at night or during adverse weather conditions, creating a safety risk related to rear-end collisions and improper signaling. The condition developed during normal vehicle use and exposure to rain and environmental moisture. No collision, impact, or external damage occurred prior to the failure. No dashboard warning messages or alerts were observed prior to discovering the issue. The vehicle was inspected by an authorized dealership, which confirmed the taillight failure. The dealership stated the light source is not serviceable and that the entire taillight assembly must be replaced. The…”

“While driving my 2023 Chevrolet Bolt EUV at approximately 136,594 miles, the vehicle suddenly began making severe mechanical clacking/grinding noises and vibrating heavily. I could no longer safely drive the vehicle at normal road speed and was only able to move it very slowly. Fortunately, this occurred when traffic around me was light. If this failure had occurred in heavy or high-speed traffic, the sudden loss of normal drivability could have created a serious safety risk to me and other motorists. The vehicle was towed to Simpson Chevrolet of Irvine for diagnosis. The Chevrolet dealer found a large hole in the transmission/transaxle case and confirmed that the unit had lost all of its fluid. Diagnostic code P17C8 was also present. The dealer described this as an unusual failure. I specifically asked whether an external impact or road debris caused the damage. The dealer stated that there were no visible signs of impact to the undercarriage other than the hole in the transmission case itself and that they could not determine the exact cause. I did not shift the vehicle into Park while it was moving, and I do not recall striking any road debris or other…”