1996 Chevrolet Cavalier service brakes, hydraulic problems

“DT: THE CONSUMER STATED HE BOUGHT A CAR ON 6-29-05 FROM KLICK LEWIS INC. ON HIS WAY HOME WHEN HE APPLIED THE BRAKES, SUDDENLY THE CAR FELT LIKE IT WAS COMING APART. HE CALLED THE DEALER WHERE HE BOUGHT THE CAR AND THEY TOLD HIM THE VEHICLE NEEDED FRONT ROTORS. ON FRIDAY 7-15-05; BEFORE HE HAD TAKEN IT IN TO HAVE THE ROTORS PUT ON, HE NOTICED THE CAR WAS FULL OF SMOKE. HE CALLED THE FIRE DEPT. AND THEY CAME OUT AND DIFFUSED THE FIRE AND TOLD HIM THAT IT WAS AN ELECTRICAL PROBLEM AND THE CAR COULD HAVE CAUGHT ON FIRE. HE THEN CALLED THE SALESPERSON THAT SOLD HIM THE CAR AND THEY SAID THEY WOULD HAVE SOMEONE GET BACK TO HIM. HE HAS MADE 5 TELEPHONE CALLS TO THEM AND NO ONE HAS RETURNED HIS CALLS. *JB”

“WHEN BRAKES ARE APPLIED THEY ENGAGE AND RELEASE WHICH CAUSES EXTENDED STOPPING DISTANCE. THE VEHICLE STOPS WHEN THE BRAKE PEDAL IS SLAMMED ON, WHICH ENGAGES THE ABS. THE DEALERSHIP HAS CHECKED THE BRAKE ROTORS , PADS, ALL COMPONENTS IN THE FRONT SUSPENSION AND TIRES. THEY WE FINE. THE CAUSE OF THE FAILURE IS STILL UNKNOWN. *NM *BF *NM”

“DRIVING DOWN THE ROAD, MOTOR STOPS RUNNING AND I LOST ALL POWER BOTH STEERING AND ELECTRICAL. GOT IT TO THE SIDE OF THE ROAD. WAITED 2 MINUTES AND STARTED IT BACK UP IT WAS FINE. ONLY DID THIS 2 TIMES WITHIN A WEEK PERIOD. ENGINE IDLE ROUGH SINCE I PURCHASED IT IN 1998. TOOK IT IN AND THEY SAID THEY COULD NOT FIND ANYTHING. CAME BACK SEVERAL TIMES THEY ESSENTIALLY SAID THAY COULD DO NOTHING THATS JUST HOW THEY RUN. MOTOR SURGES AND LAGS AFTER START UP. REGARDLESS OF TEMPERATURE. PUSH PEDAL MOTOR BOGS DOWN AND THEN IT WILL TAKE OFF. REPLACED ALMOST EVERY SENSOR UNDER THE HOOD PROBLEM IS STILL PRESENT. BATTERY TOOK A DUMP AT ALMOST 4 YEARS. ENGINE SPUN #3 AND #4 BEARINGS ON A COLD START UP. THEY ADVISED ME THAT I NEEDED A WATER PUMP AT THE SAME TIME.PASS POWER WINDOW WAS ALWAYS SLOW. REPLACED APPROX MID 2002 REAR SUSPENSION CLUNKS AND SOUNDS LIKE IT HAS LUMBER IN THE TRUNK. WHEEL STUDS SNAP EASILY AS I HAVE REPLACE APPROXIMATELY 10. REAR BRAKES DRAG AND GRAB EVEN AFTER REPLACEMENT. FRONT BRAKES WEAR EXCESSIVELY. RUBBER MUFFLER HANGER WEARS OUT. REPLACED 2 TIMES.”

“WHILE DRIVING AT HIGHWAY SPEEDS OR FOR EXTENDED PERIODS OF TIME FOUR-SPEED OVERDRIVE TRANSMISSION WILL AUTOMATICALLY SHIFT DOWN TO A LOWER GEAR, AND "ETS OFF" AND "CHECK ENGINE" LIGHTS COME ON SIMULTANEOUSLY. VEHICLE REMAINS IN LOW GEARS UNTIL LIGHTS GO OFF OR UNTIL VEHICLE COOLS DOWN. ALSO , THAT WHEN THIS PROBLEM OCCURS VEHICLE JERKS AND VIBRATES AS IF THE ABS IS KICKING IN AT SPEEDS IN EXCESS OF 40 MPH. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK”

“TWO TIMES IN THE LAST YEAR, THE ANTI-LOCK BRAKES ON OUR 1996 CHEVROLET CAVALIER HAVE MALFUNCTIONED AND CAUSED US TO REAREND OTHER VEHICLES. BOTH TIMES AFTER SLAMMING DOWN ON THE BRAKES, THE CAR WOULD ALMOST COME TO A COMPLETE STOP AND THEN WOULD JUT FORWARD 2-3 TIMES AND HIT THE CAR IN FRONT OF US. AFTER THE FIRST ACCIDENT, WE TOOK THE CAR TO A MECHANIC, AND HE TOLD US HE COULD NOT FIND ANYTHING WRONG WITH THE ANTI-LOCK BRAKES. WE THOUGHT THAT POSSIBLY IT WAS JUST A ONE TIME OCCURRENCE AND MAYBE THERE WOULD NOT BE CONTINUING PROBLEMS WITH THE BRAKES, BUT THEN IN THE LATEST ACCIDENT, OUR CAR BEHAVED IN THE SAME MANNER. THIS TIME WE SUSTAINED SEVERE DAMAGE AND THE CAR WAS TOTALED. LUCKILY, NO ONE WAS INJURED IN EITHER ACCIDENT, PROBABLY BECAUSE BOTH TIMES THE ACCIDENTS OCCURED AT VERY LOW SPEEDS. WE WOULD LIKE TO KNOW IF OTHER OWNERS OF 1996 CHEVROLET CAVALIERS HAVE HAD SIMILAR PROBLEMS WITH THEIR ANTI-LOCK BRAKES. THANK YOU. *AK”

“ENGINE HEAD GASKET/STRUTS/STARTER/TRANSMISSION/ DOME LIGHT/ PAINT/,MUFFLER/SEATS AND ABS BRAKES HAVE ALL GONE BADLY AT LEAST ONCE, AND SOME HAVE BEEN REPLACED TWICE AND ARE BAD AGAIN. DEALER WAS NOTIFIED SEVERAL TIMES, BUT REFUSED TO CHECK OR REPLACE. NO LONGER DOING BUSINESS WITH THEM DUE TO THE SERVICE. I HAVE BEEN HAVING TO PAY FOR ALL OF THE SERVICES. *AK”