2004 Chevrolet Colorado suspension problems

“Mechanic had the truck on the lift raised up to check the brakes for squeaking and while under the truck the mechanic inspected the frame because he noticed a lot of rust and called me to come look at it and pointed out that the frame has rotted to the point that he should not be driven and could break in half and cause major problems for the safety of the occupants and other drivers on the road. I looked up online if other Colorado owners had the same issue and others have the same problem. I’m am forced to junk this vehicle even though the rest of the truck is in very good condition”

“THE FRAME OF THE TRUCK ROTTED AND IS NO LONGER DRIVEABLE WITHOUT A CHANCE OF AN ACCIDENT. THE PA INSPECTION IS ABOUT TO RUN OUT ALSO AND WILL NOT PASS INPECTION. I BOUGHT THIS TRUCK USED AND JUST PAID IT OFF AND WAS HOPING I WAS CLEAR OF ANY VEHICLE PAYMENTS. AT THIS POINT THERE IS NO WAY I WILL EVEN GET CLOSE TO WHAT I PAID FOR IT AS IT IS ONLY GOOD FOR SCRAP. I AGREE WITH ANOTHER POST I SAW ON HERE THAT SAID IF TOYOTA HAD TO RECALL THEIR VEHICLES FOR THE SAME REASON THEN WHY DOES GM NOT HAVE TO DO THE SAME THING? IT ONLY SEEMS RIGHT. I KNOW THEY HAVE HEARD OF THIS ISSUE BUT ARE JUST TRYING TO BRUSH IT UNDER THE RUG HOPING IT DOESN'T COME UP. HOPING YOU HAVE OUR BACK ON THIS WITH TRYING TO PROTECT THE CONSUMER.”

“VEHICLE HAS 96,800 MILES, AND THE FRAME HAS COMPLETELY RUSTED THROUGH CAUSING THE REAR SUSPENSION TO DETACH FROM THE FRAME, AS WELL AS THE BED TO DETACH FROM THE FRAME. VEHICLE IS NO LONGER ABLE TO BE PUT ON LIFT TO HAVE TIRES ROTATED AS THE FRAME DISINTEGRATES UPON CONTACT. THIS IS A VERY WELL KNOWN PROBLEM, AND I AM CURIOUS WHY THE FEDERAL GOVERNMENT HAS NOT FORCED GM TO RECALL THESE VEHICLES LIKE TOYOTA WAS FORCED TO DO WITH THEIR IDENTICAL SITUATION. DO YOUR JOBS, AND HOLD THESE CORPORATIONS ACCOUNTABLE FOR CHEAP WORKMANSHIP.”

“TL* THE CONTACT OWNS A 2004 CHEVROLET COLORADO. THE CONTACT DISCOVERED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY CORRODED. THE CONTACT EXPRESSED CONCERN THAT THE CORROSION CENTERED AROUND THE SUSPENSION AND SUBFRAME SPRING MOUNTS. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.”

“THE FRAME HAS ALOT OF RUST PLUS THE FRAME IS CRACKED AND THE BACK,THE ENGINE LIGHT IS ON YOU CAN NOT GET A RESPONSE FROM THE PLUGING UNIT. WHE YOU TO CHECK THE PROBLEM.”

“SEVERE RUST / ROT ON THE FRAME BOTH ON THE MAIN FRAME AS WELL AS THE FRONT FRAME WORK TO THE POINT THAT A SALVAGE YARD DECLARED IT UNSAFE TO DRIVE. DISCOVERED WHEN I HAD TO REPLACE THE REAR DIFFERENTIAL WHICH ALSO SNAPPED DUE TO RUST.”