2004 Chevrolet Colorado visibility problems

“THIS INCIDENT OCCURRED TWICE. IT INVOLVES THE HEATER BLOWER MOTOR RESISTOR ASSEMBLY. 8 YEARS AGO MY DAUGHTER USED PUT HER BACK PACK ON THE PASSENGER FLOOR WHERE IT REPEATEDLY MADE IMPACTED THE CONNECTION TO THE BLOWER MOTOR RELAY ASSEMBLY. THIS EVENTUALLY CAUSED THE PIN AND SOCKET ON THE ORANGE WIRE TO SEPARATE TO THE POINT WHERE IT ARCED AND BURNT. I FOUND AND REPAIRED THE SOCKET WHEN THE HEATER WOULD ONLY WORK ON HIGH. ON THE 16TH OF DEC 2013, A PASSENGER SIZE 12 SHOES ACCIDENTALLY, AND UNWITTINGLY KICKED THE SAME SPOT AND CAUSED THE SAME FAULT. I REPAIRED THE SOCKET AGAIN. MY COMPLAINT IS THE RESISTOR CONNECTION IS IN A SPOT TO EASILY SERVICE, BUT IT IS IN A VULNERABLE SPOT FOR ACCIDENTAL CONTACT. I BELIEVE IT NEEDS A ROBUST PROTECTIVE COVER, EITHER METAL OR PLASTIC. FOR PEOPLE THAT CANNOT REPAIR THEIR OWN VEHICLES, THIS SITUATION COULD COST THEM A COUPLE OF HUNDRED DOLLARS. MY OTHER ELECTRICAL FAULT IS THE RIGHT SIDE WINDOW MOTOR. IT QUIT WORKING COUPLE OF YEARS AGO, AND I WAS ABLE TO TAKE IT APART AND CLEAN THE BRUSHES. IT WORKED FOR A COUPLE OF YEARS UNTIL IT STOPPED A COUPLE OF WEEKS AGO. I REPLACED THE MOTOR BECAUSE I COULD NOT FIND BRUSHES TO REPLACE.…”

“INTERMITTENT NON WORKING POWER DOOR LOCKS WIPERS HEADLIGHTS AND WINDOWS! THERE ARE HUNDREDS OF THESE INCIDENTS POSTED ONLINE. THERE LOOKS TO BE THOUSANDS OF DOLLARS IN REPAIRS WITH NO SOLUTION! *KB”

“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”

“OWNED THIS 2004 COLORADO EXT.CAB 4X4 SINCE NEW. * AGAIN * BLOWER MOTOR CONTROLLER ON A/C QUIT WORKING ON SPEEDS 1,2,3 STILL WORKS ON "HIGH" 4. THIS IS THE 3RD FAILURE SINCE NEW, AND I'VE HAD TO PAY FOR REPAIRS TWICE ALREADY. ACCORDING TO REPORTS ON INTERNET PROBLEM IS WITH RESISTOR MODULE THAT CONTROLS THE SPEED OF THE BLOWER. SPOKE TO TWO DIFFERENCE GM DEALERS,AND HE ADVISED THAT THE PROBLEM WAS WITH THE MODULE OVERHEATING AND CAUSING THE PLUG TO MELT AND CAUSE THE RESISTOR PACK TO BECOME INOPERABLE. NO WARRANTY ON PART ACCORDING TO GM DEALER. THIS IS A MANUFACTURER DEFECT AND SAFETY HAZARD THAT COULD CAUSE RISK OF FIRE, INJURY OR DEATH. THIS ISSUE NEEDS TO BE COVERED UNDER A RECALL OR SOME PROGRAM TO PROTECT CONSUMERS FROM PAYING TO REPAIR THE SAME DEFECTIVE PART OR SYSTEM OVER AND OVER AGAIN ! *TR”

“2004 CHEVY COLORADO ZQ8 HVAC BLOWER HARNESS AND RESISTOR. PART WAS REPLACED AT APPROXIMATELY 15,000 MILES UNDER MFG WARRANTY WITH IDENTICAL PARTS. AGAIN OUT OF WARRANTY WITH NO NEW REVISED PARTS AT 45,000 AND NOW AGAIN AT 77,000 MILES. HARNESS AND RESISTOR FAILURE HAD GOTTEN SO HOT EACH TIME THAT IT HAD MELTED THE HARNESS TO THE RESISTOR. POSSIBLE FIRE HAZARD, WITH SEVERELY BURNT WIRES. LOOKING IT UP ON FORUMS THIS IS COMMON ON ALL GM MODEL COLORADO AND CANYON TRUCKS, GM KNOWS OF THE PROBLEM, BUT REFUSES TO OFFER A REVISED PART OR REAL SOLUTION. *TR”

“I HAVE A 2004 CHEVY COLORADO. THE PROBLEM I AM HAVING WITH MY VEHICLE IS THE A/C SWITCH WILL NOT WORK ON SETTING 1 THROUGH 3. ALTHOUGH 4 WORKS ALL THE TIME. I HAVE HAD IT FIXED 3 TIMES SINCE I BOUGHT THE TRUCK BY A CHEVY DEALER YET THE PROBLEM KEEPS HAPPENING, AND ONCE AGAIN IT HAS STOPPED WORKING. I HAVE READ MANY AUTOMOBILE FORUMS AND IT SEEMS MANY PEOPLE ARE HAVING THE SAME PROBLEM YET CHEVY HAS YET TO ISSUE A RECALL. *TR”