2011 Chevrolet HHR fuel/propulsion system problems

“Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.”

“Fuel line/gas leaking from faulty tube carrying ignitable flammable fluid...no warning just smell and sighting at stop..went to savoy IL dealer immediately and had replaced @ 1k cost approx. 2+ yrs ago...cel”

“I left vehicle running on my concrete driveway while I ran in the house to get my father for an errand. When I came outside and went to get into the vehicle I noticed a fire in the front of the rear wheel on the driver's side kind of dripping flames from the vehicle on to the concrete. Luckily I reacted quickly enough to release the parking brake. [Car is a manual transmisson]. The car drifted forward [driveway has small downhill pitch]and I turned the motor off. Then I [luckily] ran over to a hose and brought it to the vehicle to extinguish the fire.”

“Fuel line is rusted and leaking. This is apparently in numerous models and prior years as well. This metal piece on the fuel line is leaking. Fuel leaks out no matter how short of time you drive. I’m concerned with a fire and live on a fixed disability income and it’s food or the vehicle which I need to get to the doctor.”

“While refueling the vehicle several weeks ago I noted a strong smell of gasoline. I did not see any visible fuel leak at the gas station. Drove the vehicle home approximately 10 miles, 20 minutes travel time. Gasoline smell persisted. On exit from the vehicle the smell became strong and I observed a liquid dripping/pooling under the vehicle on the driveway. Drips were occurring from the driver side rear of the vehicle slightly in front of the left rear wheel approximately 6 inches interior from the edge of the vehicle. After 15 minutes the drips subsided. Vehicle has not been used or moved since this incident.”

“Fuel brake line on driver's side rear wheel corroded and sprung a leak. Leaky area was wrapped in a heat protecting shield and which probably collected water and caused the excessive corrosion. I notice many other similar complains regarding Chevy HHRs.”