1997 Chevrolet Malibu engine and engine cooling problems

“INTAKE MANIFOLD ON MY 1997 CHEVY MALIBU HAS STARTED TO GO BAD I KNOW ITS THE LOWER GASKET I CALLED CHEVY AFTER SEEING SO MANY OTHER PEOPLE WITH THE SAME PROBLEM I WAS TOLD CHEVY WOULD NOT REPLACE IT DUE TO IT BEING OVER TEN YEARS OLD WELL IT SEEMS LIKE WITH WAS A PROBLEM WAITING TO HAPPEN AS SOON AS THEY SEALED THE MANIFOLD AT THE FACTORY I THINK GM SHOULD REPLACE THIS ITEM ONCE FREE OF CHARGE PER CAR ALSO MY RACK AND PINION SEEMS TO STICK ON MY LEFT SIDE I'VE REPLACED THE POWER STEERING PUMP AND CHECKED THE RACK AND PINION SEEMS THE BALL BEARING WANTING TO COME OUT OR IS GONE I TOLD GM I DON'T THINK THEY REPLACED IT WHEN THEY RECALLED IT AND THEY TOLD ME THE FIRST OWNER DID BUT WONT SEND ME PAPERWORK ON THE REPAIR OR THE DEALERSHIP THAT DID THE WORK. *TR”

“I HAVE A 1997 CHEVY MALIBU (54,000) MILES THAT SEIZED UP IN TRAFFIC DUE TO ANTIFREEZE IN THE OIL. I HAVE RECENTLY LEARNED THAT THE ANTIFREEZE (DEXA-COOL) USE BY GM HAS A LONG HISTORY OF CAUSING PREMATURE ENGINE FAILURES BY EATING AWAY THE GASKETS, WATER PUMPS AND OTHER ASSOCIATED ENGINE COOLING COMPONENTS. I?M NOT ABLE TO TAKE ADVANTAGE OF THE CLASS ACTION LAW SUIT SINCE MY PROBLEM HAPPENED LONG AFTER THE CLOSING DATE. I FEEL A NATIONAL RECALL SHOULD BE INITIATED BY NHTSA. *TR”

“AUTOMOTIVE COOLING SYSTEM> VEHICLE BEGAN LOOSING COOLANT ON DRIVEWAY. TOOK VEHICLE TO REPAIR SHOP. WAS INFORMED THAT VEHICLES ENTIRE COOLING SYSTEM WAS CORRODED. AND NEEDED TO BE REPLACED. THE CAUSE WAS ATTRIBUTED TO THE USE OF THE COOLANT DEX-COOL THIS WAS REQUIRED BY GENERAL MOTORS TO KEEP UP WARRANTY ON THE VEHICLE. NOW I FIND THAT THIS WAS THE WRONG THING TO USE AND I WILL BE OUT $1800 IN REPAIR WORK. I BELIEVE G.M. SHOULD BE RESPONSIBLE FOR THE LARGEST PART OF THIS EXPENSE. *TR”

“I WOULD LIKE TO GET A REPLACEMENT,DISCOUNT OR FREE SERVICE ON MY 1997 MALIBU. I'VE HAD MY CAR SINCE 2004 AND HAD TO GET ANOTHER MOTOR IN 2005 WHICH IS NEEDED NOW .THIS CAR HAS PUT ME DOWN A LOT NOT ONLY PROBLEMS WITH THE MOTOR BUT THE IGNITION LOCKED UP AND I HAD TO REPLACE THAT AS WELL AS THE BRAKES AND ROTORS THAT LAST ABOUT 2 OR 3 MONTHS. I ALSO HAVE A PROBLEM WITH THE LIGHTS NOT WORKING PROPERLY THEY ONLY WORK ON HIGH BEAM. I CAN'T FIND A MORE REASONABLE MECHANIC THAT'S WILLING TO REPAIR THE MOTOR THAT I CURRENTLY HAVE DUE TO THE TYPE WHICH IS A 2.4 AND A USED MOTOR COST ABOUT HALF THE PRICE OF A NEW ONE. PLEASE HELP! *TR”

“I WAS DRIVING MY CAR ON THE BYWAY AND TOOK THE INTERSTATE MERGE LANE WHILE INCREASING MY SPEED TO MERGE INTO TRAFFIC I FELT A SNAP IN MY STEERING WHEEL AND GAS PEDAL, I THEN LOST THE DASH AND THE CAR IMMEDIATELY OVERHEATED, I HAD NO REAL POWER TO TURN THE WHEEL AND THE GAS PEDAL WAS A LOOSE PUSH. BEING THAT I HAD MERGED ONTO THE INTERSTATE WHEN THIS OCCURRED I HAD TO DRIVE AN ADDITIONAL 5 MILES TO THE NEXT EXIT. NOT EVERYONE HAS A CELL PHONE. WHEN I GOT TO THE NEXT EXIT I WAS ALMOST UNABLE TO TURN THE WHEEL ENOUGH TO GET IT INTO THE NEAREST PARKING LOT, IT WAS HARDER TO TURN THAN MY FIRST TRUCK A 1959 FORD TWIN I BEAM PICKUP. I FORTUNATELY DIDN'T HIT ANY ONE OR ANYTHING. UPON RAISING MY HOOD AFTER PARKING THE CAR I AM APPALLED TO SEE THAT THE TENSIONER PULLEY AND ONE OF THE IDLER PULLEYS ARE GONE AND MY SERPENTINE BELT IS SHREDDED. I HAVE REPLACED THE PARTS BUT SINCE THEN I ALSO FOUND THAT WITHIN 5 MILES THE "DREADED" GASKETS THAT SO MANY PEOPLE HAVE COMPLAINED ABOUT, AND MINE WE ALREADY EATING FLUIDS IN SIPPS BEFORE THIS, WERE GONE. I HAVE REPLACED THE BROKEN PULLEYS SERPENTINE BELT ALTERNATOR WATERPUMP AND GASKETS NOT A MONTH LATER THE OTHER IDLER PULLEY THAT…”

“TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING 55 MPH THE CONTACT SMELLED ANTIFREEZE AND NOTICED SOME ON THE ENGINE. THE MECHANIC STATED THAT THE MANIFOLD GASKET WAS DEFECTIVE. THE FAILURE WAS REMEDIED AT APPROXIMATELY 50,000 MILES. THIRTY DAYS LATER THE SAME FAILURE OCCURRED. ONCE AGAIN, THE MECHANIC STATED THAT THE MANIFOLD GASKET WAS DEFECTIVE AND PERFORMED THE REPAIRS. THE FAILURE RECURRED. THE MANIFOLD GASKET WAS REPLACED ON TWO MORE OCCASIONS. THE CURRENT MILEAGE IS 80,000 , AND FAILURE MILEAGE WAS 50,000. *AK”